Transcript
����� Automotive South Africa QUICK CATALOGUE 2014
ABS Components-Truck/Bus
34
Line Filter
23
ABS/EBS - Speed Sensors
38
Load Regulating Valve
12
Adaptor Valves
13
Load Sensing / Lev elling Valve Parts
32
Load Sensing Valves -Air Susp
19
Load Sensing Valves -Mech Susp
18
Air Dryers Air Processing Units
9 10
Air Reservoirs
13
Low Pressure Switches
12
Air Throttle Valv es
29
Non-Return Valves
25
Brake Chambers
29
Nylon Pipes
33
Brake Chambers -Disc Brakes
30
Operating Cylinders
27
Pressure Limiting Valves
12
Cartridges - Desiccant
9
Charging Valves
11
Proportional Valves
27
Clutch Serv os
24
Quick Release Valves
20
Compressors
5
Raise / Lower Valve
23
Condensor Drain Valves
13
Relay Emergency Valves
21
Couplings (Duomatic)
28
Relay Valves
22
Couplings (F & J)
29
Rubber Hose
33
Couplings (Palm)
28
Cylinder Heads
8
Safety Valves
25
Servo - Air / Hydraulic
26
Diagnostic Software
40
Shut-Off Cock
21
Diaphragms
32
Silencers
28
Door Control Valve
28
Solenoid Valves
27
Double Check Valves
25
Spiral Binding
33
Double Diaphragm Spring Brakes
31
Spring Boxes
19
Double Diaphragm Spares
31
Spring Brakes
30
Drain Valv es
13
Spring Brakes W edge
30
EBS Components - Tr ai ailer s
36
Spr in ing Br ak ake s - Di Disc Br ak ak es es
30
EBS Components - Truck
34
Spring Brake Spares
31
EBS Software
40
Stop Light Switches
12
ECAS Truck Components
35
Suzy Pipes
33
Electrical Suzy
33
Test Equipment ABS
40
Empty Load Valves
13
Test Equipment Pneumatic
41
Exhaust Brake Valves
25
Throttled Check choke Valve
25
Foot Brake Valves
14
Trailer Control Valves
20
Four Circuit Protection Valves
11
Trailer Release Valve (PREV)
21
Gearbox / Control / 3/2-way
26
Unloader Valves
9
Governor Valves
9
Hand Control Valves
15
FITTINGS CATALOGUE
Levelling Valves
23
Compression Fittings
43
Lift Axle Control Valves
38
Push In Fittings
49
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 1/53
�����
PARTS CATALOGUE 2014
TRUCK COMPONENTS
1 Suction Strainer
14 Brake Chamber
2 Compressor
15 Foot Brake Valve
3 Air Dryer
16 Park Brake Valve
4 Four Circuit Protection Valve
17 Trailer Control Valve
5 Reservoir Circuit 2 (Front Brakes)
18 Relay Load Sensing Valve
6 Reservoir Circuit 1 (Rear Brakes)
19 Spring Brakes
7 Reservoir Circuit 3 (Park Brakes / Trailer)
20 Relay Valve
8 Reservoir (Regeneration)
21 ABS ECU
9 Exhaust Brake Valve
22 ABS W arning Lamps
10 Pressure Gauges
23 ABS Solenoid Valve (Front)
11 Coupling (Red) Emergency Line
24 ABS Solenoid Valve (Relay)
12 Coupling (Yellow) Service Line
25 Power Supply Cable (Trailer)
13 Non Return Valve
26 Stop Light
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 3/53
�����
PARTS CATALOGUE 2014
TRAILER COMPONENTS
27 Coupling (Red) Emergency Line
40 ABS Solenoid Relay Valve (Steering Axle)
28 Coupling (Yellow) Service Line
41 Brake Chamber
29 ABS Power Supply Cable
42 Spring Brake
30 ABS Diagnostic Cable
43 Spring Brake
31 Line Filter 32 Line Filter 33 Park Shunt Valve 34 Relay Emergency Valve 35 ABS ECU 36 Air Reservoir 37 Relay Load Sensing Valve 38 ABS Modulator Relay Valve 39 Quick Release Valve
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 4/53
�����
PARTS CATALOGUE 2014
COMPRESSORS 411 411 003 003 000 000 0 411 003 001 0 411 003 011 0
150cm3 - Self Lube (75mm Bore) 411 003 000 0 Superceded to 411 003 011 0
ASA5272 ASA5273 4 1 1 0 03 3 4 0 4 4 1 1 1 41 6 2 3 2 ASA6282 4 1 1 0 03 7 3 3 2 A97/147 4 3 2 6 00 0 0 0 0
Gasket kit including oil seal Ring Set (75mm Bore) Con Rod Bearing Piston Complete Head Kit fo f or 411 003 011 0 only Con rod Complete Pulley 8" Diam Filter - W et et Suction
411 034 501 0
Sing ingle Cylin linder der Com Comp presso essorr
229cm . UD (Rotation Forced Oiling.) MERCEDES 355 AC (Air Cooling). 2800 RPM max. Vickers. Flange. (90mm Bore)
ASA5280 ASA5281 ASA5410 ASA6501 4 1 1 0 42 3 4 0 4 4 1 1 0 42 3 4 1 4 411 04 042 62 620 2
Head Kit Gasket kit including oil seal Ring Set 90mm Complete Repair Kit Main Bearing Bush Con rod Bearing per half Piston Co Complete wi with ri rings
411 041 845 0 ASA5277 ASA5278 ASA5273 4 1 1 0 42 3 4 0 4 4 1 1 0 42 3 4 1 4
411 141 000 0
Head Kit Gasket kit including oil seal Ring Set 75mm Main Be Bearing Bush Con rod Bearing per half
Single Cylinder (75mm Bore) Mono block DEUTZ / IVECO / BELL COMPRESSOR
4 1 1 0 42 3 4 1 4 4 1 1 1 41 2 0 5 4 ASA5273 ASA6312 ASA6313 A97/147 4 1 1 1 41 6 2 3 2
411 411 143 143 805 805 0
Con Rod Bearing per half Main Bush Ring Set 75mm Head Kit Gasket Kit Pulley 8" Diam Piston and Rings
293c 293cm m . UD. UD. AC. 3000 3000 RPM RPM max max (90m (90mm m Bore Bore)) DEUTZ / IVECO COMPRESSOR
ASA 5371 8 9 7 3 16 9 9 9 4 8 9 7 6 70 1 9 0 4 8 1 1 4 08 0 4 0 4 ASA 5410 4 1 1 1 41 2 0 5 4
Head Kit ADE 407 Gasket (not in kit above) “O” Ring Front Oil Seal Ring Set 90mm Bush
411 142 711 0
229cm Single Cylinder UD. 3000 RPM max ( 90mm Bore)
4 1 1 1 42 6 2 3 2 4 1 1 1 42 6 5 1 4 ASA 5410 4 1 1 1 42 0 0 2 2
MERC 1924 Piston and Rings Cylinder Head Ring Set 90mm Gasket Kit only
3
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 5/53
����� COMPRESSORS
PARTS CATALOGUE 2014
Continued…… 3
411 145 507 0
Water Cooled, UD, 203cm (75mm Bore) 3000 PRM Vickers Flange. MAN
4 1 1 0 41 0 5 0 4 4 1 1 0 41 0 5 1 4 4 1 1 0 42 3 4 1 4 411 14 141 62 62 3 2 4 1 1 1 45 0 0 0 2 411 411 145 145 653 653 2 ASA5273
Valve Plate ( no not in kit) Leaf Valv e (not in kit) Con Rod Bearing per half Pis to ton Co Complete wi with rirings 75 75mm Gasket Kit Cyli Cylind nder er head head onl only (NO (NO GASKE ASKET T wit with h hea head) d) Ring Set 75mm
412 352 003 0
352cm UD, 3000 PRM ( 85 85mm Bore) Watercooled MAN
4 1 2 3 52 0 0 1 2 9 1 1 0 04 2 0 2 4 9 1 1 5 01 6 2 4 2 9 1 1 1 45 7 3 8 2 4 1 2 3 52 9 2 4 2 8 9 5 0 73 5 8 9 4 ASA6690
Gasket Kit Main Be Bearing Bush Piston W itith Rings 85mm Co n R o d Cylinder He Head L sh shape Sump (w (welsh) Pl Plug Ring set Per Piston 85 85mm
411 411 151 151 003 003 0
411 15 151 00 009 0
Sing Single le Flan Flange ge Comp Compre ress ssor or (85m (85mm m Bor Bore) e) Flange, Water Cooled 411 151 008 0 supercedes MERCEDES Supercedes 41 411 15 151 00 008 0
411 411 154 154 002 002 2 9 1 1 5 01 6 2 4 2 4 1 1 1 54 0 0 0 2 4 1 1 1 51 0 5 2 4 ASA6690
Cyli Cylind nder er Head Head ( Incl Includ udes es gask gasket et)) old old no 411 411 154 154 800 800 2 Piston and Rings Gasket Kit Gasket Barrel to Valv e Pl Ring set Per Piston 85 85mm
352cm3. UD. WC. 3000 RPM max. Flange Compressor (85mm Bore) ACTROS / ATEGO / BELL Supercedes: 411 154 000 0 and 411 154 003 0
412 154 004 0
Mercedes Number: A9061 304915 4 1 1 1 54 8 0 0 2 9 1 1 5 01 6 2 4 2 9 1 1 1 45 7 3 8 2 4 1 1 1 54 0 0 0 2 411 411 151 151 052 052 4 ASA6690
Cylinder Head & Gasket Piston and Rings Co n R o d Gasket Kit Gask Gasket et Barr Barrel el to Valv Valve e Pla Plate te (Inc (Incll in in gas gaske kett kit kit abov above) e) Ring set Per Piston 85 85mm
412 412 352 352 027 027 0
Sing Single le Cyl Cyl Wat Water er Cool Cooled ed (85m (85mm m bore bore)) 3 352cm . UD. WC. 3000 RPM max. Replaces 412 352 016 0 & 412 352 014 0 AXOR
9 1 1 5 01 6 2 4 2 ASA6690 4 1 2 3 52 9 2 3 2 4 1 2 3 52 9 2 2 2
Piston and Rings Ring set Per Piston 85 85mm Gasket Kit Cylinder Head
A457 131 01 80
MUST USE Flange Seal **** **** only from Merc dealers ***
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 6/53
����� COMPRESSORS
PARTS CATALOGUE 2014
Continued……
412 412 704 704 008 008 0 412 704 001 0 412 704 004 0 412 704 005 0
Twin Twin Cyli Cylind nder er with with PR (Pow (Power er Redu Reduct ctio ion) n) Valv Valve e 3 704cm . WC. (85mm bore) VO LV LVO FH12 ( 20 20701801)
412 70 704 93 93 2 2 4 1 2 7 04 9 2 0 2 9 1 1 5 01 6 2 4 2 911 505 732 2 ASA6690
Cylinde r Head c/ c/w me metal ga gas ke ket Gasket kit Piston with rings x2 Conrod Conrod Ring set Per Piston 85 85mm
412 412 704 704 014 014 0
Twin Twin Cyli Cylind nder er with with PR (Pow (Power er Redu Reduct ctio ion) n) Valv Valve e S/S 412 704 006 0 VOLVO FM9
4 1 2 7 04 9 3 3 2 9 1 1 5 01 6 2 4 2 ASA6690
Head & Gasket Piston and Rings Ring set Per Piston 85 85mm
412 412 704 704 015 015 0
Twin Twin Cyli Cylind nder er with with PR (Pow (Power er Redu Reduct ctio ion) n) Valv Valve e 704cm . WC. (85mm bore) 3 Hole Mounting Off Centre Centre VOLVO (20845313)
412 70 704 93 933 2 ASA6690 9 1 1 5 01 6 2 4 2
Head & Gasket for 41 412 70 704 01 015 0 Ring set Per Piston 85 85mm Piston and Rings
412 412 704 704 018 018 0
Twin Twin Cyli Cylind nder er with with PR (Pow (Power er Redu Reduct ctio ion) n) Valv Valve e S/S 412 704 015 0 704cm . WC. (85mm bore) 3 Hole Mounting Off Centre Centre VOLVO (21172036)
412 70 704 94 940 2 ASA6690 9 1 1 5 01 6 2 4 2
Head & Gasket for 41 412 70 704 01 018 0 Ring set Per Piston 85 85mm Piston and Rings
911 911 142 142 000 000 0
229c 229cm m Singl ingle e Cy Cylin linder der (90 (90m mm bor bore) e)
4 1 1 1 42 6 2 3 2
Piston and Rings
911 504 506 0
Twin Cylinder WC. 443cm . UD. WC. (75mm bore) bore) 3000 RPM max. max. DAF 95X COMPRESSOR COMPRESSOR Replaces Replaces 911 504 504 0 (1736785)
9 1 1 5 04 9 2 0 2 4 1 1 1 41 6 2 3 2 A6608 9 1 1 5 04 9 2 3 2
Cylinder Head Piston with Rings x2 Ring Set x2 75mm Gasket Kit
911 506 505 0
440cm , UD. WC. 3000RPM. Flange (75mm Bore) Steering Pump IVECO Bus
9 1 1 5 06 9 2 8 2 4 1 1 1 41 6 2 3 2 911 911 506 506 924 924 2 A6608 ASA7073
Gasket Kit Piston with Rings Kit Kit (Bo (Botttom) om) Wel Welsh sh plug plug and and fro front nt bear bearin ing g Ring Set x2 75 75mm Repair kit complete
3
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 7/53
����� COMPRESSORS
PARTS CATALOGUE 2014
Continued……
911 506 054 0
Twin Cylinder 440cm3 (75mm Bore) Flange Compressor IVECO
9 1 1 5 06 6 9 1 4 9 1 1 1 45 7 3 4 2 4 1 1 1 41 6 2 3 2 9 1 1 5 06 9 2 5 2 A6608
Crankshaft Co n R o d Piston Cylinder Head Ring Set x 2 75 75mm
M100960
Single Cylinder 160cm Air Cooled Cooled (65mm Bore) TATA
M111410 MSP1/226 MSP1/216
Valve Plate Ring Set Gasket Kit
3
412 100 805 2 S/S Water Water Coole Cooled d Head Head 412 100 806 2 MAN F2000 Note: Excluding Cylinder Head Gasket
412 412 090 090 803 803 2 412 090 801 2
MAN MAN TGA TGA - COM COMP PRES RESSOR HEA HEAD ONL ONLY Y NO GASKET with Head
4 1 2 0 90 9 2 1 2
For TGA buy 2 heads (51 541146081)
411 411 033 033 801 801 2
ADE ADE 400 400 COM COMPL PLET ETE E HEA HEAD (TH (THIN IN PLAT PLATE) E) - M/B M/BEN ENZ Z
ASA5371
Head kit
912 551 001 0 912 912 551 551 002 002 0
476cm . UD. WC. (85mm bore) 3000 RPM max. UD (NIS (NISSA SAN N DIE DIESE SEL) L) -Com -Compr pres esso sorr excl exclus usiv ive e to to UD UD COMPRESSOR HEAD ONLY
9 1 2 5 51 9 2 1 2 ASA6690
Cylinder Head Ringset Per Piston 85mm
912 510 103 0
912 912 510 510 104 104 0
Twin Cylinder WC. 636cm . UD. WC. (85mm bore) bore) 3000 RPM max. max. AXOR Use Use 912 912 510 510 103 103 0 Mov Move plug plug as requ requir ired ed
9 1 2 5 10 9 2 0 2
Cylinder Head
A457 131 01 80
MUST USE Flange Seal **** **** only from Merc dealers ***
3
VARIOUS 411 553 003 0 4 1 1 5 53 9 2 1 2
ATEGO BUS S/S 411 553 001 0 repair kit
911 50 505 15 150 0 9 1 1 5 05 0 0 1 2
TW IN IN CO COMPRESSOR VO VOLVO FL FL7 repair kit
911 506 505 0 9 1 1 1 53 5 2 5 0 9 1 1 1 54 5 1 0 0 9 1 1 1 54 9 2 0 2
TW IN IN 75MM BORE (IVECO) CUMMINS Only CUMMINS Only Head for 911 154 500 0
911 155 521 0
SINGLE CYLINDER VW
Universal Cylinder Head 4 12 7 0 4 9 40 2
Head & Gasket for the following Compressors
412 70 4 018 0 9 12 5 1 2 0 08 0 912 514 003/4 0 912 55 1 002 0
VOLVO VOLVO Renault Nissan
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 8/53
�����
PARTS CATALOGUE 2014
UNLOADER AND GOVERNOR VALVES
975 303 473 0 / 474 0
275508
Part Number
Cut Out Pressure
Repair Kit
9 7 5 3 03 4 7 3 0 9 7 5 3 03 4 7 4 0 2 7 55 0 8
8.1 Bar 2 Port 8.1 Bar 4 Port 7.6 Bar (cut in 5.8bar) 5.8bar)
975 303 0 0 1 2 975 303 0 0 1 2 2 6 72 3
Service Kit ASA 5698 ASA 5698 ASA 5699
Description
Port size
General Truck / Bus General Truck / Bus ERF, Scania, International
M22 x 1.5 M22 x 1.5 1/8"
GENERAL AIR DRYERS
432 410 083 0
432 410 113 / 117 0 / 202 0
Part Number 4 3 2 4 10 0 0 0 0 4 3 2 4 10 2 0 0 0 432 4 10 10 02 2 0 432 410 083 0/095 0 43 2 4 1 0 10 1 0 4 3 2 4 10 1 1 1 0 432 432 410 410 113 113 0 432 432 410 410 117 117 0 432 432 410 410 202 202 0 4 3 2 4 10 1 2 0 0 432 432 410 410 720 720 0 4 3 2 4 15 0 2 9 0 4 3 2 4 15 0 5 5 0 4 3 2 4 15 1 3 8 0 432 4 20 20 00 2 0 432 432 421 421 008 008 0 4 3 2 4 31 0 0 8 0 432 4 32 32 27 9 0 932 932 400 400 001 001 0 932 4 00 00 00 2 0 932 4 00 00 00 5 0 932 932 400 400 024 024 0 Note Note 4 3 2 4 25 1 0 5 0 N o t e 932 510 004/5 0 /6 0 43 2 4 1 0 55 2 2
NOTE AIR DRYERS:
432 420 002 0 / 008 0
Unloader
Repair kits Dryer
Cartridge
Cut Out Pressure
4 3 2 4 1 0 0 01 2 4 3 2 4 1 0 0 01 2 4 32 32 410 001 2 4 32 4 1 0 0 01 2
4 3 2 4 10 0 0 2 2 4 3 2 4 10 0 0 2 2 432 4 10 10 002 2 432 410 002 2
4 32 410 222 7 4 32 410 222 7 4 32 32 410 222 7 4 3 2 4 10 9 27 2
8.1 Bar 8.1 Bar 9.5 Bar 9.3 Bar
432 432 410 410 001 001 2 432 432 410 410 001 001 2 432 432 410 410 001 001 2
432 432 410 410 002 002 2 432 432 410 410 002 002 2 432 432 410 410 002 002 2
432 432 410 410 222 222 7 432 432 410 410 222 222 7 432 432 410 410 222 222 7
432 432 410 410 001 001 2 No Repair Kit
432 432 410 410 002 002 2
432 432 410 410 222 222 7 43 2 410 222 7
12. 12.5 Bar 10 Bar Bar 8.1 8.1 bar bar 12.5 Bar 12. 12.5 Bar 8.3 Bar 10 Bar 10 Bar 13 Bar 13 Bar Bar
4 32 32 410 001 2
4 32 32 410 001 2 432 432 410 410 001 001 2 4 32 32 410 001 2 4 32 32 410 001 2 432 432 410 410 001 001 2
ASA7070
ASA7015 Note: 432 425 920 2 A6645
432 4 1 5 921 2 432 4 1 0 002 2 432 4 10 10 002 2 432 432 410 410 002 002 2 432 4 3 1 002 2 432 4 32 32 000 2 932 932 400 400 000 000 2 932 4 00 00 000 2 932 4 00 00 000 2 932 932 400 400 000 000 2 4 32 4 1 0 0 0 2 2 932 51 0 956 2
4 32 32 410 222 7 432 432 410 410 222 222 7 4 3 2 4 10 2 2 2 7 4 32 32 410 222 7 432 432 420 420 220 220 2 4 32 32 420 220 2 4 32 32 420 220 2 432 432 420 420 220 220 2 4 3 2 9 0 1 2 23 2
10 Bar 12 Bar Bar 12 Bar 12 Bar 12 Bar Bar 13 Bar
932 400 024 0
Description / Application W itith 24V Heater same as …200 0 W itith 24V Heater cut out pressure tag W itith 24V Heate r Por t 4 M12 Snap on Exha us ust. Nis sa sa n W itith 24V heater & port 4/23 PR v alv e line Scania Superceded to 432 410 202 0 Superceded to 432 410 113 0 port22 M16 not M12 No Heat Heater er.. Snap nap on Exha Exhaus ust. t. Voss Voss.. MAN MAN No Heat Heater er.. Snap nap on Exha Exhaus ust. t. Voss. oss. MA MAN F200 F2000 0 Snap Snap on Exha Exhaus ust. t. Voss. oss. Gene Genera rall Use Use Pisto iston n A664 A6645 5 Superseded to 432 410 720 0 wit with Unl Unloade oader, r, MAN, AN, TGA TGA,TGL, TGL,TG TGS S,TGM TGM W ith Heater. ERF. Hino Similar to Rockwell Air dryer Renault Similar to Rockwell Air dryer No Heate r Pt 4 M12 Por ts ts M2 2 Mer c Volv o No Heat Heater er Unlo Unload ader er Pt 4 M16&M 16&M22 22 Snap nap on Exh. xh. Voss Voss W ith Heater. Pt M22 Twin Cannister. Volv o. W itith Heater . Twin Can ni nis te ter . Volv o. o. No Heat Heater er.. for for APU 932 932 500 500 001 001 0/00 0/006 6 0 No port port 4 W itith Heater . f or or APU 932 5 00 00 00 5 0 No por t 4 No Heate r. r.fo r APU 932 5 00 00 013 0 w itith p or ort 4 Ac tr tr os os Repl Replac aces es 010/ 010/ 020/ 020/ 050 050 Kit Kit ASA7 ASA701 015 5 with with mods mods Actro Actros s Replaces 432 425 001 0/ 101 0 ECAD Volvo FH FM SCANIA 932 510 958 2 Quad Valv e (No PC Board) Exhaust
Repairs 432 410 … to 432 421 …. Dryer and Unloader section & include Vers A & B spares Version B Piston 432 410 622 4 Version A Piston A6645 Repairs 932 400 001 0 / 002 0 / 005 0/ 024 0 Solenoid Kit Piston (Brass)
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 9/53
�����
PARTS CATALOGUE 2014
AMERICAN VEHICLE AIR DRYERS
432 432 413 413 003 003 0
0.7 0.7 Backf ackfllow. ow. 12v 12v With ith heate eaterr INTERNATIONAL Rockwell Airdryer Port 4 = 1/4" NPT. Cut-out Pressure 7.9bar
432 413 925 2 432 420 926 2 4 3 2 4 13 9 3 4 2 4 3 2 4 13 9 2 9 2 ASA6953 4 3 2 4 10 2 2 2 7
Check Valve Bypass Valve Turbo Cut-off Purge Valv e Service Kit Cartridge
Old No 432 413 928 2
AIR PROCESSING UNITS 932 932 500 500 006 006 0
Comb Combin inat atio ion n Air Air dry dryer and and Fou Fourr Cir Circu cuit it MERCEDES ACTROS
932 400 001 0 934 705 005 0
432 432 415 415 055 055 0
Air Dryer Quad valve
Comb Combin inat atio ion n Air Air dry dryer and and Fou Fourr Cir Circu cuit it UD Trucks
932 932 500 500 007 007 0
Comb Combin inat atio ion n Air Air dry dryer and and Fou Fourr Cir Circu cuit it MERCEDES ACTROS
932 500 006 0
932 400 002 0 9 3 4 7 05 0 0 5 0
Air Dryer S/S 932 400 024 0 Quad Valve
Repair Kit : 432 410 001 2 9 3 2 4 00 0 0 0 2 432 420 220 2
Unloader kit Dryer kit Cartridge
934 705 005 0
AIR DRYER INSTALLATION KIT 7186210
4324102020 8114010324 8114010804 8282519086 8930100204 8930402104 8935111104 8938000140 8938000220 AGA179
AIR DRYER SINGLE UNLOADER WASHER 12MM ALUMINIUM WASHER 22MM ALUMINIUM NYLON PIPE 6 X 1MM BLACK PLUG M22 X 1.5 NYLON INSERT 6 X 1 PIPE CLAMP 6MM UNION M12 X 1.5 X 6MM UNION M22 X 1.5 X 6MM AIR RESERVOIR 5L X 8"
AIR DRYER CARTRIDGES
432 410 226 2
432 420 220 2
Part Number
Port Thread
4 3 2 4 10 2 2 6 2 4 3 2 4 20 2 2 0 2 4 3 2 4 10 2 2 2 7 4 3 2 9 01 2 2 3 2 4 3 2 4 10 2 4 4 2
G 1 1/4" . M39 x 1.5 . M39 x 1.5 . M39 x 1.5 . M39 x 1.5 .
432 410 222 7
432 901 223 2
432 410 244 2
Description
Application
Max 13 Bar Max 20 Bar. Wi Without ‘O’ Ring Operating 13 Bar W ith 'O' Ring Air System Protector 13 Bar + 'O' Ring Air System Protector Plus 13 Bar
Scania Superceded by 432 410 927 2 Mercedes Actros General. Use in place of 432 410 020 2 Extracts oil carry over Improved ASP for heavy contaminant and oil
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 10/53
�����
PARTS CATALOGUE 2014
MULTI CIRCUIT PROTECTION VALVES
934 702 210 /221/250 0
934 702 100 0/ 300 0/ 350 0
934 714 …….
434 700 003 0
934 705 005 0
….040 0
Part Number
Opening pressure Bar 21 22 23 24
9 3 4 7 02 0 4 0 0 9 3 4 7 02 2 1 0 0 9 3 4 7 02 2 2 1 0 9 3 4 7 02 2 5 0 0 9 3 4 7 02 1 0 0 0 9 3 4 7 02 2 6 0 0 9 3 4 7 02 3 0 0 0 9 3 4 7 02 3 2 0 0 9 3 4 7 05 0 0 5 0 9 3 4 7 14 0 10 0 9 3 4 7 14 0 03 0 9 3 4 7 14 1 10 0 9 3 4 7 14 2 11 0 9 3 4 7 14 1 37 0 9 3 4 7 14 4 00 0 9 3 4 7 14 1 28 0 9 3 4 7 14 1 40 0 9 3 4 7 14 7 40 0 9 3 4 7 14 1 45 0 9 3 4 7 14 1 51 0 4 3 4 7 00 0 03 0 932 500 501 1
6.0 7.0 7.0 7.0 7.0 7.0 7.0 7.0 9.0 6.9 6.9 6.9 6.5 6.2 6.9 6.5 6.3 6.3 6.5 6.5 5.2
6.0 7.0 7.0 7.0 7.0 7.0 7.0 7.0 9.0 6.9 6.9 6.9 6.5 6.2 6.9 6.5 6.3 6.3 6.5 6.5 5.2
5 .5 7 .0 7 .0 7 .0 6 .0 7 .0 7 .0 7 .0 7 .5 7 .0 6 .9 7 .0 7 .4 6 .2 6 .9 7 .4 5 .8 5 .8 7 .2 7 .5 N/A
897 181 531 4
5 .5 7 .0 7 .0 7 .0 6 .0 7 .0 7 .0 7 .0 7 .5 6.9 6.9 6.9 6.5 6.2 6.9 6.5 5.8 5.8 6.5 6.5 N/A
Description 10 Bar 5 Port Supp-M22 Del-M16 10 Bar 7 Port Supp-M22 Del-M16 20 Bar 7 Port Supp-M22 Del-M16 20 Bar 5 Port Supp-M22 Del-M16 10 Bar 5 Port Supp-M22 De Del-M16 20 Bar 5 Port All ports M22 20 Bar 5 Port Supp-M22 Del-M16 20 Bar 5 Port Supp-M22 De Del-M16 13 Bar 23/24 limited 8.5Bar ports M22 13 Bar 5 Port Port1-M22 Del-M16 13 Bar 5 Port 3/8" NPTF/1/2"NPTF 13 Bar Bar 5 Por Portt Port Port11-M2 M22 2 Del-M Del-M16 16 13 Bar Bar 5 Por Portt Port Port11-M2 M22 2 Del-M Del-M16 16 13 Bar 5 Por Portt 934 934 705 705 001 001 2 13 Bar 5 Por t M22 V OS OSS 13 Bar Bar 5 Por Portt Port Port11-M2 M22 2 Del-M Del-M16 16 13 Bar Bar 7 Por Portt Port Port11-M2 M22 2 Del-M Del-M16 16 13 Bar Bar 7 Por Portt Port Port11-M2 M22 2 Del-M Del-M16 16 13 Bar Bar 7 Por Portt Port Port11-M2 M22 2 Del-M Del-M16 16 13 Bar Bar 5 Port Port Port Port1-B 1-Brac racke ketD tDel el-M -M16 16 10 bar 2 Port All ports M22 Pressure Sensor for 934 705 005 0
Application
Repair kit
4 Circuit General Truck/Bus General Truck/Bus General Truck/Bus Merc, Iv eco, DA DAF, Renault DAF, Powerliner General Truck/Bus Truck/Bus Alt …..322 0 Merc Actros 6 port MAN Leyland, Ford, International
9 3 4 7 02 0 00 2 ASA 5735 ASA 5736 ASA 5394 ASA 5393 9 3 4 7 02 0 0 4 2 ASA 5391 ASA 5735 9 3 4 7 05 0 01 2
Replaces 934 714 128 0 MAN TGA SCANI SCANIA A Repl Repl 934 714 2110
Volvo FAW Direct mounting Mercedes Benz
4 3 4 7 00 0 03 2
Diaphragm only available in kit 935 705 001 2
CHARGING VALVES VALVES
(Single Circuit Circuit Protection Valves, Overflow Overflow Valves )
Part Number
Opening pressure
Port size
Repair kit
Description
4 3 4 1 00 0 2 3 0 4 3 4 1 00 0 2 4 0 4 3 4 1 00 0 3 4 0 4 3 4 1 00 1 2 2 0 4 3 4 1 00 1 2 3 0 4 3 4 1 00 1 2 4 0 4 3 4 1 00 2 2 0 0 4 3 4 1 00 2 2 2 0 4 3 4 1 00 2 2 4 0 4 3 4 1 00 2 2 7 0 4 3 4 1 00 2 2 8 0 89 7 1 3 1 74 1 4
5.5 Bar 6.0 Bar 6.8 Bar 4.5 Bar 5.0 Bar 5.5 Bar 4.5 Bar 6.2 Bar 1.7 Bar 5.5 Bar 6.4 Bar
M22 x 1.5 M22 x 1.5 M22 x 1.5 M22 x 1.5 M22 x 1.5 M22 x 1.5 M22 x 1.5 M22 x 1.5 M22 x 1.5 M22 x 1.5 M22 x 1.5
ASA5699 ASA5699 ASA5699 ASA5699 ASA5699 ASA5699
W ith return flow W ith return flow W ith return flow No return flow No return flow No return flow W ith Limited return flow W ith Limited return flow W ith Limited return flow W ith Limited return flow W ith Limited return flow Diaphragm for 434 100 . . . . . . .
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 11/53
�����
PARTS CATALOGUE 2014
PRESSURE LIMITING VALVES (Regulators) (Regula tors)
475 009 026 0
475 010 010 0 / 017 0
Part Number
Limiting Pressure
47 5 0 0 9 00 8 0 4 7 5 0 09 0 26 0 4 7 5 0 10 0 10 0 4 7 5 0 10 0 17 0 4 7 5 0 10 3 00 0 4 7 5 0 10 3 01 0 4 7 6 0 10 3 07 0 4 7 5 0 10 3 10 0 4 7 5 0 10 4 00 0 4 7 5 0 15 0 01 0 4 7 5 0 15 0 04 0 4 7 5 0 15 0 09 0 4 7 5 0 20 0 06 0 4 7 5 0 10 3 33 0 4 7 5 0 15 0 61 0 4 2 1 3 55 9 31 2 4 7 5 0 15 0 14 0
0.7 Bar 3.0 Bar 4.0 Bar 0.35 Bar 8.5 Bar 10.0 Bar 1.8 Bar 4.0 Bar 8.0 Bar 7.4 Bar 3.5 Bar 5.3 Bar 4.4 Bar 9.3 Bar 7.2 Bar 7.2 Bar 3 Bar
475 010 300 0 / 301 0
Port size M12 x 1.5 M12 x 1.5 M22 x 1.5 M22 x 1.5 M22 x 1.5Voss M22 x 1.5 M22 x 1.5 M22 x 1.5 M22 x 1.5 Voss M16 x 1.5 M16 x 1.5 M16 x 1.5 M22 x 1.5 M22 x 1.5 Voss M16 x 1.5 M16 x 1.6 M16 x 1.5
475 010 400 0
Repair kit
475 015 001 0 / 004 0
Description / Application MAN Merc MAN Scania Merc Iv eco Merc MAN MAN
4 7 5 0 1 0 0 00 2 4 7 5 0 1 0 0 00 2 4 75 0 1 0 0 0 1 2 4 7 5 0 1 0 0 01 2 4 7 5 0 1 0 0 01 2 4 7 5 0 1 0 0 01 2 4 75 0 1 0 0 0 2 2 4 7 5 0 1 5 0 01 2 4 7 5 0 1 5 0 01 2 4 7 5 0 1 5 0 01 2
Only available in kit
DAF Merc MAN Merc Iv eco MAN Renault For Actros. W ith Silencer MAN TGA, TGM, TGL kit 421 355 931 2 Ex E xcl. to ZF includes 475 015 061 0 EBS Mech Susp - Old D EBS Trailer only
STOP LIGHT SWITCHES (Normally open, open, Cut in Switch)
262625
441 014 002 0
441 014 001 0 / 021 0
Part Number
Actuation Pressure
2 6 26 2 5 44 1 0 1 4 00 1 0 4 4 1 0 14 0 0 2 0 4 4 1 0 14 0 2 1 0 4 4 1 0 14 1 9 0 0
0.34 Bar (5 psi) 2 Bar 1 Bar 0.5 Bar 0.15 Bar
Port size 1/2 NPT M12 x 1.5 M10 x1 tapered M12 x 1.5 M12 x 1.5
Description / Application Normally open Normally open Normally open Normally open Normally open
General Truck / Bus General Truck / Bus N/S General Truck / Bus General Truck / Bus MAN General Truck / Bus
LOW PRESSURE SWITCHES (normally closed, cut off)
441 014 010 0
AGA987 AGA987 includes 441 014 101 0
Part Number
Actuation Pressure
AGA987 4 4 1 0 14 1 0 1 0 4 4 1 0 14 0 0 4 0 4 4 1 0 14 0 1 0 0 4 4 1 0 14 0 1 3 0 4 4 1 0 14 0 1 4 0 4 4 1 0 14 0 1 5 0 4 4 1 0 14 0 2 5 0
4.5 Bar (65 psi) 4.5 Bar 5.5 bar 0.3 Bar 4.0 Bar 4.5 Bar 5.0 Bar 6.0 Bar
Port size 1/4" NPT M12 x 1.5 Fem M12 x 1.5 M12 x 1.5 M12 x 1.5 M12 x 1.5 M12 x 1.5 M12 x 1.5
Description / Application Normally closed General Truck / Bus. Supercedes: 970 100 031 1 Normally closed General Truck / Bus M1 M12 female Fits 6mm union Normally closed General Truck / Bus Normally closed General Truck / Bus Normally closed General Truck / Bus Normally closed General Truck / Bus Normally closed General Truck / Bus Normally closed General Truck / Bus
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 12/53
�����
PARTS CATALOGUE 2014
RESERVOIRS Part Number AGA 179 195mm 0 5 1 0 10 0 0 4 M 0 5 1 0 15 0 0 5 M 0 5 1 0 20 0 0 6 M 0 5 1 0 20 0 1 1 M 0 5 1 0 30 0 1 1 M 4 5 1 0 40 3 1 1 M 4 5 1 0 60 3 1 1 M 9 5 0 4 05 0 0 1 0 A6741
Length 1 95 m m 3 55 m m 507 mm 660 mm 4 11 m m 579 mm 7 40 m m 1 0 95 m m 185mm 860mm
1 6 75 0 62 M A6104 4 5 1 9 99 2 7 6 2 A6742
Diameter 206mm 8" 8" 206mm 8" 206mm 8" 8" 206mm 8" 8" 276mm 11" 276mm 11 11" 276mm 11" 276mm 11" 206mm 8" 8" 390mm
Description 5 Litre Reserv oir 10 Litre Reserv oir 15 Litre Reserv oir 20 Litre Reserv oir 20 Litre Reserv oir 30 Litre Reserv oir 40 Litre Reserv oir 60 Litre Reserv oir 4.5 Litre Reservoir 90 Litre Reserv oir 30kg "Fatboy"
11 " 8" 11 "
Mounting Bracket. Pair for 11" Mounting Bracket. Single for 8" Mounting Bracket Strap type Mounting Bracket Strap 90 litre
4 x M22 Ports
451 999 276 2
1675062 M
DRAIN VALVES
Condensor Drain (water trap)
934 300 003 0 / 006 0
934 301 000 0
Part Number
Port Thread
9 3 4 3 00 0 0 3 0 9 3 4 3 00 0 0 6 0 SF1280 934 934 301 301 000 000 0 934 3 01 01 00 3 0 432 432 511 511 000 000 0 4 3 4 3 00 0 0 0 0
M22 x 1.5 1/2" NPT 1/4" NPT M22 M22 x 1.5 1.5 M22 x 1.5 M22 M22 x 1.5 1.5 M12 x 1.5
432 511 000 0
Description Manual W ith Pull Ring Manual Manual Wi With Pull Ring Autom utomat atic ic Repa Repair ir kit kit: 934 934 301 301 000 000 2 Filt Filter er:: 899 899 380 380 622 622 4 Diap Diaphr hrag agm: m: 897 897 121 121 400 400 2 Auto ma matic R ep epair kit: 93 4 301 000 2 Filter : 89 899 38 0 622 4 Cond Conden enso sorr Drai Drain n valv valve e Max 10 Bar. ar. Merc. Merc. Repa Repair ir kit kit: 432 511 511 000 000 2 Filte ilter: r: 432 432 511 511 220 220 4 Automatic. R ep epair kit: 434 300 000 2
RATIO VALVES / EMPTY LOAD VALVES / ADAPTER VALVES
473 300/ 301 0…..
975 001 000 0
Part Number
Port Threads
47 3 3 0 0 00 1 0 47 3 3 0 0 00 4 0 47 3 3 0 1 00 0 0 473 301 001 0 473 301 002 0 473 301 003 0 97 5 0 0 1 00 0 0 975 002 001 0 97 5 0 0 2 01 7 0
M22 x 1.5 M16 x 1.5 M22 x 1.5 M22 x 1.5 M22 x 1.5 M22 x 1.5 M22 x 1.5 M22 x 1.5 M22 x 1.5 M16 x 1.5
975 002 001 0
Repair Kit
Description Empty Load Valve. Reduces front axle braking with empty load Empty Load Valve. Reduces front axle braking with empty load. Reducing Valve. Regulating ratio:2 :1 Application: General Truck Reducing Valve. Regu lating ratio:1.5 :1 Application: General Truck Reducing Valve. Regulating ratio:1.35 ratio:1.35 :1Application: :1Application: General Truck Reducing Valve. Regulating ratio: 1.15 :1 Application: General Tr uck Adapter valve. Adjusting Valve 0.6 to 0.8 Bar. Bar. Adapter Valve. Knick feature Appl: DAF, Mercedes Benz, MAN MAN Adapter Valve. Application: Mercedes Benz.
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 13/53
�����
PARTS CATALOGUE 2014
FOOT VALVES
461 315 008 0 / 004 0 / 042 0
461 319 250 0
461 319 008 0
461 315 180 0
461 319 274 0
Part Number
Port Thread
Repair Kit
Description / Application
4 6 1 3 07 3 9 9 0
M22 x 1.5
461 307 002 2
Dual Circuit. Predominance 0.25Bar Elbow Exhaust. Merc
461 315 008 0
8x M16 x 1.5
461 315 005 2 461 315 915 2
Week 20/2001 Week 21/2001
Dual Circuit. Predominance: 0.3Bar 0.3Bar No Pedal Elbow Exhaust. Merc, Iveco, Scania
461 315 004 0
4x M16 x 1.5 2x M12 x 1.5
461 315 005 2 461 315 915 2
Week 20/2001 Week 21/2001
Dual Circuit. Predominance: 0.3Bar 0.3Bar Elbow Exhaust. Merc, Iveco, Scania
461 315 042 0
8x M16 x 1.5 2x M12 x 1.5
461 315 900 2 461 315 917 2
Week 20/2001 Week 21/2001
Dual Circuit. NO Predominance Predominance No Pedal Elbow Exhaust. Merc, Iveco, Scania
461 315 907 2 461 315 924 2
Week 20/2001 Week 21/2001
Dual Circuit. NO Predominance Predominance No Pedal Push In fittings, with silencer, Scania
461 315 180 0
No Pedal
No Pedal
461 315 263 0 NLA Use 461 315 264 0
4x M22 M22 x 1.6 1.6
461 461 315 914 914 2 461 315 927 2
Week Week 20/2 20/200 001 1 Week 21/2001
No Pedal Application: Axor. Short Silencer 39.9mm Dia 4 x M8 stud Mounting
461 315 264 0
2x M16/ 2x M22 461 315 914 2 2x M12 x 1.5 461 315 927 2
Week 20/2001 Week 21/2001
No Pedal Application: Axor. Short Silencer 39.9mm Dia 4 x M8 stud Mounting
461 317 021 0
8x M16 x 1.5
461 319 008 0
8x M16 x 1.5 1x M12 x 1.5
461 319 007 2 461 319 908 2
Week 20/2001 Week 21/2001
Dual Circuit. Predominance: 0.3Bar No Pedal Integrated Empty Empty Load function 1,5:1. Merc, DAF
Elbow Exhaust.
461 319 018 0
8x M16 x 1.5 1x M12 x 1.5
461 319 007 2 461 319 908 2
Week 20/2001 Week 21/2001
Dual Circuit. Predominance: 0.3Bar No Pedal Integrated Empty Load function 2:1. Merc, DAF
Elbow Exhaust.
461 319 250 0
4x M22 x 1.5 1x M16
461 319 004 2 461 319 905 2
Week 20/2001 Week 21/2001
Dual Circuit. Predominace : 0.4Bar Merc. Elbow Exhaust
461 319 270 0
4x M22 x 1.5 1x M16 x 1.5
461 319 002 2 461 319 903 2
Week 20/2001 Week 21/2001
Dual Circuit. Predominance: 0.3Bar 0.3Bar No Pedal Elbow Exh. Exh. Integrated Empty Load 2 :1. Merc Econoliner
461 319 271 0
4x M22 x 1.5
461 319 006 2 461 319 907 2
Week 20/2001 Week 21/2001
Dual Circuit. Predominance: 0.4Bar 0.4Bar Exhaust : Pipe Merc.
461 319 273 0/272 0
2x M22 x 1.5 3x M16 x 1.5
461 319 901 2 461 319 912 2
Week 20/2001 Week 21/2001
Long curved silencer. silencer. 69mm dia Voss 4 x M8 stud Mounting Application: Axor Axor / Atego Atego
461 319 274 0
2x M22 x 1.5 3x M16 x 1.5
461 319 901 2 461 319 912 2
Week 20/2001 Week 21/2001
No Pedal Small Silencer 39.9mm Dia 4 x M8 stud Mounting Application: Axor.
461 491 102 0
M22 x 1.5
4 61 3 0 7 0 02 2 Boot 897 752 670 4
461 494 502 0
PI
461 317 792 2
Dual foot valve with Pedal. No Gauge ports
Powerliner
No Pedal
Predominance: 0.25Bar Dual Circuit, Application: Renault Treadle Assembly
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 14/53
�����
PARTS CATALOGUE 2014
FOOT VALVES VALVES Continued ……...
470 012 000 0
Part Number
Port Thread
Repair Kit
Description / Application
461 499 005 0
4x 2x 4x 2x 3x
461 499 000 2
Predominance: 0.25Bar. Dual Circuit.
470 012 000 0 467 406 102 0
M22 x 1.5 M12 x 1.5 M16 x 1.5 M14 x 1 M14 x 1.5
461 307 002 2 470 012 520 2 467 406 004 2
Kit Slave Cylinder
Actros
Dual (Hydraulic / Pneumatic) Brake Valve with slave cylinder. Merc Hydraulic Brake Foot Valve Spool Diametre: Diametre: 14mm Medium: Mineral Mineral Oil
467 406 202 0
6x M16 x 1.5 2x M12 x 1.5
Hydraulic Brake Foot Valve Spool Diametre: Diametre: 20mm Medium: Mineral Mineral Oil
467 406 208 0
6x M16 x 1.5 2x M10 x 1
Hydraulic Brake Foot Valve Spool Diametre: Diametre: 14mm Medium: Mineral Mineral Oil
961 106 000 0
2x M14 x 1.5
961 106 000 2
Air foot valve. Trailer control for tractors.
ROTARY HAND BRAKE VALVES 961 961 701 701 110 110 0 961 961 701 701 115 115 0 961 701 100 0
Antinti-cl cloc ockw kwis ise. e. M14 M14 x 1.5 1.5 Thr Threa ead. d. 3 Por Port. t. Diff Differ eren entt Hand Handle le - Anti nti cloc clockw kwis ise e Clockwise Appl Applic icat atio ion n : DAF, DAF, Merc, Merc, Iveco Iveco
9 6 1 7 02 1 5 4 4 8 9 9 7 55 0 2 1 4 ASA 5221
Guide Pin Roller Service Kit
961 961 702 702 014 014 0
Antinti-cl cloc ockw kwis ise e M14 M14 x 1.5 1.5 Thre Thread ad.. 4 Port Port.. With Test Position MERCEDES, MAN
9 6 1 7 02 1 5 4 4 8 9 9 7 55 0 2 1 4 ASA 5222
Guide Pin Roller Service Kit (9 (961 701….)
961 961 703 703 001 001 0
M14 M14 x 1.5 1.5 Thr Threa ead. d. With With Cont Contro roll Por Portt To To Trailer 4 Port
9 6 1 7 03 0 0 0 2 ASA 5324
Repair Kit Service Kit
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 15/53
�����
PARTS CATALOGUE 2014
HAND CONTROL VALVES
961 721 000 0
961 723 017 0
961 721 004 0
961 723 019 0
961 721 045 0
961 721 040 0
961 723 104 0
961 723 100 0
961 722 252 0
Part Number
Port Thread
961 721 000 0
M14 x 1.5
9 61 7 21 0 04 / 8 2
Input Pressure: 8.5 Bar. Output Output Pressure: 7.5 2 port Side Bar. Stroke 90o. M14 x 1.5 Thread. Mercedes Benz
961 721 004 0
M14 x 1.5
9 6 1 7 21 0 0 4 2
Input Pressure: Pressure: 15 Bar. Output Pressure: 7.5 2 Port Side Centre Bracket Lock Position. DAF, Iveco, Scania, Volvo
961 721 008 0
1/4" NPT
961 721 004/8 2
Input Pressure: 8.5 Bar. Output Output Pressure: 7.5 Side Bar. 2 Port. Centre Bracket. Bracket. General Truck / Bus
961 721 040 0
M14 x 1.5
961 721 004/8 2
Input Pressure: 8.5 Bar. Output Pressure: 7.5 Bar. Side Return. 2 Port. Merc
961 721 004/8 2
Stroke 73º Voss. 2 Port Slide VOSS. VOSS. (Left Hand Side Bracket). Without Test Position. Merc
961 721 045 0
Repair Kit
961 722 232 0
Description / Application
9 6 1 7 22 0 02 2
Spring
961 722 230 0
Slide x 2
961 722 232 0
Slide x 3
Repair Kit 961 722 003 2 Service Kit ASA 6939
Stroke 73º Voss. 3 Port Slide VOSS. (Left Hand Side Bracket). With Test Position. Merc
961 722 252 0
M14 x 1.5
Repair Kit
961 722 003 2 961 722 924 2 ASA 6939
Stroke 73º. Position 85º. 3 Port. (Left Hand Side Bracket). Test Position. Merc, DAF Use 961 722 272 0 & Turn bracket
With
961 722 258 0
M14 x 1.5
961 722 003 2 961 722 924 2 ASA 6939
Stroke 73º . 3 Port. (Centre Bracket). With Test Position. Ports Application: Merc
Side
961 722 264 0
M14 x 1.5
Stroke 73º. 4 Port. Without Test Position. Side Bracket Application: Merc
Service Kit
961 722 004 2 961 722 924 2 ASA 6995
961 722 272 0
M14 x 1.5
Repair Kit Service Kit
961 722 003 2 ASA 6939
Stroke 73º. 3 Port. (Right Hand Side Bracket). With Test Position. Application: International Use 961 722 252 0 & Turn Bracket
961 722 284 0
M14 x 1.5
Repair Kit Service Kit
961 722 003 2 ASA 6939
Stroke 73º. 4 Port (Side) Centre Bracket. Without Test Position. Merc
961 722 288 0
M16 x 1.5
Repair Kit 961 722 003 2 Service Kit ASA 6939
Stroke 73º Thread. 3 Port Port (Side) Right Hand Side Bracket. With Test Position. Merc Econoliner
961 722 314 0
M14 x 1.5
Repair Kit 961 722 007 2
Stroke 73º Thread. 3 Port (Side) Side Bracket. With Test Position. Scania
961 723 017 0
M16 x 1.5
961 723 004 2
Stroke 85º 2 Port (Side) Centre Bracket. Without Test Position. DAF
961 723 019 0
M16 x 1.5
961 723 000 2
Stroke 73o VOSS Ports. 2 Port (Side) Lock Position. Centre Bracket. Without Test Position replaces 9617230050 Application: MAN
961 723 100 0
M16 x 1.5
961 723 000 2
Stroke 73º VOSS 3 Port (Bottom). Centre Bracket. With Test Position. Position. Application: MAN
Service Kit Repair Kit Service Kit Repair Kit
Stroke 73º Voss. 2 Port Slide VOSS. (Left Hand Side Bracket). Without Test Position. Merc
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 16/53
�����
PARTS CATALOGUE 2014
HAND CONTROL VALVES Continued …………..
961 723 118 0
961 723 125 0
961 723 203 0
Part Number
Port Thread
961 723 104 0
M16 x 1.5
961 723 000 2
Stroke 73º with Parking Position 85º VOSS Push-in Fitting. 3 Port (Side). Centre Bracket. With Test Position, 5.5Bar . Merc
961 723 117 0
M16 x 1.5
961 723 000 2
With Control Port To To Trailer. With Electrical Switch. NO Lock Bracket. Application : Iveco
961 723 118 0
M14 x 1.5
Stroke 73º VOSS Push-in Fitting. 3 Port (Side). Lo ck Position. Centre Bracket. With Test Position. Position. Application: MAN
961 723 124 0
M16 x 1.5
Stroke 73º VOSS Ports. 3 Port (Side) Centre Bracket. With Test Position. Application: Merc
961 723 125 0
M16 x 1.5
Stroke 73º VOSS 3 Port (Side). Lock Position with Test Position. Position. Application: Merc Actros
961 723 203 0
M16 x 1.5
961 724 204/5 0
Repair Kit
961 723 405 0
Description / Application
961 723 000 2
3 Ports (Bottom). 5.9 Bar Output. Centre Bracket. With Test Position. Application: ERF
961 961 724 724 926 926 2
Volvo olvo Only nly Kit avai availa labl ble e to After fterma mark rket et part numbers: 20367533 and 20367534
961 723 213 0
M16 x 1.5
3 Ports (Bottom). With Test Position. Application: ERF
961 723 217 0
M16 x 1.5
3 Ports Stroke 73º (Side Ports). With Test Position. Application: Scania
961 723 405 0 (inverted) Normally open 961 723 201 0
M16 x 1.5
9 6 1 7 23 0 01 2 961 723 934 2
Stroke 73º. 2 Port (Bottom). Stretch Brake Centre Bracket. Without Test Position. Application: DAF, MAN MAN
M16 x 1.5
9 6 1 7 23 0 00 2
3 Ports (Side). 5.5Bar Centre Bracket.
961 723 421 0
M16 x 1.5 Voss
Stroke 73º. 2 Port (Side). Without Test Position. Application: ACTROS MPII
961 723 426 0
M16 x 1.5
Stroke 73º. 2 Port (Side). Centre Bracket. Without Test Position. Application: MAN MAN
262395M
TC2 hand Control dashmounted - import on request only
Part Number
Port Thread
AGA969
1/8"
Repair Kit
Description / Application Manouevering Valve, Push and hold button
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 17/53
Centre
Volv Volvo o
�����
PARTS CATALOGUE 2014
LOADSENSING VALVES ( Mechanical Mechanic al )
475 710 ……
Part Number
475 713 501 0
Port 1
Port 2
475 722 / 720 ….
Port 4
475 800 301 0
Control Angle
475 604 011 0
Description
47 5 7 0 1 02 0 0
M22 x 1.5
M22 x 1.5
30 °
Loadsensing Valve
Repair kit: 475 701 000 2
47 5 7 0 2 02 2 0
M22 x 1.5
M22 x 1.5
30 °
Loadsensing Valve
Repair kit: 475 702 001 2
47 5 7 1 0 00 0 0
M16 x 1.5
M16 x 1.5
M16 x 1.5
60 °
Relay Loadsensing
Repair kit 475 710 001 2
47 5 7 1 0 00 8 0
M22 x 1.5
M16 x 1.5
M16 x 1.5
60 °
Relay Loadsensing Repair kit: 475 710 001 2 Service kit: ASA5381 Roller: 475 710 130 4 Plunger: 475
47 5 7 1 0 01 2 0
M22 x 1.5
M22 x 1.5
M16 x 1.5
60 °
Relay Loadsensing MAN L2000, M2000
Repair kit: 475 710 001 2
47 5 7 1 0 01 6 0
M22 x 1.5
M22 x 1.5
M16 x 1.5
60 °
Relay Loadsensing Service kit: ASA5381
Repair kit: 475 710 001 2 MAN F2000 Anti clockwise
47 5 7 1 0 02 0 0
M16 x 1.5
M16 x 1.5
M16 x 1.5
30 °
Relay Loadsensing Repair kit: 475 710 001 2 Service kit: ASA5381 Roller: 475 710 130 4 Plunger: 475 710 770 4 Merc
47 5 7 1 0 02 4 0
M22 x 1.5
M16 x 1.5
M16 x 1.5
34.5°
Relay Loadsensing ASA5381 IVECO
47 5 7 1 0 03 6 0
M22 x 1.5
M22 x 1.5
M16 x 1.5
30 °
Relay Loadsensing Repair kit: 475 710 001 2 Service kit: ASA5381 Roller: 475 710 130 4 Plunger: 475 710 770 4 General Truck / Trailer / Bus
47 5 7 1 0 04 2 0
M22 x 1.5
M22 x 1.5
M16 x 1.5
20 °
Relay Loadsensing Repair kit: 475 710 001 2 Service kit: ASA5381 Roller: 475 710 130 4 Plunger: 475 710 770 4 General Truck / Trailer / Bus
47 5 7 1 0 12 8 0
M22 x 1.5
M16 x 1.5
M16 x 1.5
30 °
Relay Loadsensing FH12 & FH16
47 5 7 1 0 13 6 0
M22 x 1.5
M22 x 1.5
M16 x 1.5
16 °
Relay Loadsensing Service kit: ASA5381
47 5 7 1 3 50 1 0
M22 x 1.5
M16 x 1.5
M22 x 1.5
33 °
4 7 5 7 13 0 0 2 0
M22 x 1.5
M16 x 1.5
M16 x 1.5
No Relay. Static Valve with Arm, Cable and Spring 475 713 000 2, 475 713 710 2 Cable& spring Trailer EBS Mech Susp. Use with 475 015 014 0 limiter
4 7 5 7 13 0 0 2 0
M22 x 1.5
M16 x 1.5
M16 x 1.5
Trailer EBS Mech Susp. Use with 475 015 014 0 limiter
475 604 011 0
M22 x 1.5
M22 x 1.5
Manual Load Apportioning Valve
4 7 5 8 00 3 0 1 0
M12 x 1.5
M12 x 1.5
Truck Tag Axle Load Regulator Repair Kit 475 800 004 2
47 5 7 2 0 00 1 0
M22 x 1.5
M22 x 1.5
M16 x 1.5
30 °
New Gen Relay Loadsensing
47 5 7 2 0 00 3 0
M22 x 1.5
M22 x 1.5
M16 x 1.5
30 °
New Gen Relay Loadsensing
DAF LF 45 & LF 55
47 5 7 2 0 00 4 0
M22 x 1.5
M22 x 1.5
M16 x 1.5
30 °
New Gen Relay Loadsensing
DAF W ith Silencer
4 7 5 7 20 0 0 5 0
M22 x 1.5
M22 x 1.5
NG8 Voss
16 °
New Gen Relay Loadsensing
Voss
Repair kit: 475 710 001 2
Repair kit 475 710 002 2
Volvo
Repair kit: 475 710 001 2 VOSS Merc
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 18/53
Kit:
�����
PARTS CATALOGUE 2014
LOADSENSING VALVES VALVES ( Air Suspension )
475 721 000 0 / 3 0 / 9 0 475 711 ……
Part Number
475 714 510 0
Port 1
Port 2
Port 4
Control 41/42
Description
47 5 7 1 1 02 4 0
M22 x 1.5
M22 x 1.5
M16 x 1.5
M16
Relay Loadsensing Repair kit: 475 711 000 2 Trailers with 30Ø bags Control Pressure: 0.6 to 4.3 Bar
47 5 7 1 1 09 6 0
M22 x 1.5
M22 x 1.5
M16 x 1.5
M16
Relay Loadsensing Repair kit: 475 711 000 2 VOSS, MAN F2000 / M2000, DAF Control Pressure: 0.45 to 6.1 Bar
47 5 7 1 1 11 5 0
M22 x 1.5
M22 x 1.5
M16 x 1.5
M16
Relay Loadsensing Repair kit: 475 711 000 2 Control Pressure: 0.45 to 6.1 Bar
Merc,
47 5 7 1 1 11 8 0
M22 x 1.5
M22 x 1.5
M16 x 1.5
M16
Relay Loadsensing Repair kit: 475 711 000 2 Actros Control Pressure: 0.5 to 3.0 Bar
Merc,
47 5 7 1 4 51 0 0
M22 x 1.5
M22 x 1.5
M16 x 1.5
M12
No Relay Function Trailers with 36Ø or 30Ø bags Control Pressure: 0.4 to 3.6 Bar
47 5 7 2 1 00 0 0
M22 x 1.5
M22 x 1.5
M16 x 1.5
M16
Max operating Pressure 13Bar Mini LSV Voss ports Application: Merc Axor
47 5 7 2 1 00 3 0
M22 x 1.5
M22 x 1.5
M16 x 1.5
M16
Max operating Pressure 13Bar Relay Application: DAF
Mini LSV Voss ports No
47 5 7 2 1 00 8 0
M22 x 1.5
NG8 Voss
NG8 Voss
M16
Max operating Pressure 10Bar = 6Bar Application: Merc Axor
Mini LSV Voss ports P4
47 5 7 2 1 00 9 0
M22 x 1.5
NG8 Voss
NG8 Voss
M16
Max operating Pressure 13Bar = 8Bar Application: Merc Axor
Mini LSV Voss ports P4
SPRING BOXES
433 302 …….
433 306 …….
Part Number
Length
Deflection
4 3 3 3 02 0 0 2 0 4 3 3 3 02 0 1 4 0 4 3 3 3 02 0 0 8 0 4 3 3 3 02 0 2 6 0 4 3 3 3 02 0 2 5 0 4 3 3 3 06 0 0 3 0
260mm 220mm 160mm 220mm 160mm 260mm
100mm 85mm 55mm 85mm 55mm 100mm
Force 20 - 35 N 2 6 - 47 N 4 0 - 11 0 N 4 9 - 11 0 N 4 0 - 11 0 N 60 - 13 0 N
Description / Application With Rubber Connector No Rubber Connector With Knuckle Connector (Ball Pivot) With Connector No Rubber Connector Without Knuckle Connector (Ball Pivot) Pivot)
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 19/53
Merc,
�����
PARTS CATALOGUE 2014
QUICK RELEASE VALVE
973 500 000 0 / 973 500 014 0
973 500 031 0
973 500 051 0
Part Number
Port 1
Port 2
Description
473 501 201 0 473 501 203 0 973 500 000 0 973 500 105 0 973 500 014 0 973 500 031 0 973 500 051 0
M22 x 1.5 M22 x 1.5 M22 x 1.5 1/2" 1/2" M22 x 1.5 M22 M22 x 1.5 1.5 x 2
M22 x 1.5 x 2 M22 x 1.5 x 2 M22 x 1.5 x 2 Oring Seal 3/8" x 2 M22 x 1.5 x 2 M16 x 1.5 1.5 x 4
With Silencer With Silencer Std Trailer Diaphragm: 897 130 794 4 Freightliner - Placed between ABS solenoids Std Trailer No Kit Diaphragm: 897 130 794 4 Additional Port 22 - M16 x 1.5 5 port Diaphragm: 897 130 794 4 With Anti compound, double check valve For EBS trailers Diaph: 897 130 794 4
TRAILER CONTROL VALVE
973 002 000 0 / 430 0
973 002 521 0
Part Number
Port Threads
97 3 0 0 2 00 0 0
M22 x 1.5
97 3 0 0 2 43 0 0
973 009 001 0
Repair Kit
480 204 001 /2 0
Description
M16 x 1.5
ASA5741 973 002 003 2 ASA5741
Predominance 0.6 Bar. (Adjustable). No Dump. Application: Merc, Iveco, MAN NO Predominance. No Dump. Application: DAF
97 3 0 0 2 52 1 0
M16 x 1.5
ASA5741
With Dump feature. Predominance 0.2 Bar (Adjustable). General Truck
9 7 3 0 09 0 0 1 0
M22 x 1.5
9 7 3 0 09 0 0 0 2
With Dump feature. Predominance 0.3. Bar (Adjustable). For VOSS Pushin Fitting. Application: Mercedes Benz, MAN - Powerliner
9 7 3 0 09 0 0 6 0
M22 x 1.5
9 7 3 0 09 0 0 0 2
With Dump feature. Predominance 0.0 Bar (Adjustable) P 41/42 10.5 Bar. P 11/43 8.5 Bar. For VOSS Push-in Fitting.
9 7 3 0 09 0 1 0 0
M16 x 1.5
9 7 3 0 09 0 0 0 2
With Dump. Predominance 0.2 Bar. With Silencer Application:
9 7 3 0 09 0 1 4 0
M16 x 1.5
9 7 3 0 09 0 0 0 2
With Dump. Predominance 0.4 Bar. Application: IVECO
9 7 3 0 09 0 1 5 0
M16 x 1.5
9 7 3 0 09 0 0 0 2
With Dump. Predominance 0.1 Bar.
Application;
Application: Volvo
480 204 001 0
Ports 11,21,22 : M22 x 1.5 Ports 42,43 : M16 x 1.5
EBS Trailer Control Valve. Superceded by 480 204 002 0 Application: DAF, Mercedes Benz, Iveco Iveco
480 204 002 0
Ports 11,21,22 : M22 x 1.5 Ports 42,43 : M16 x 1.5
EBS Trailer Control Valve. Voss Ports. Port 6 (Electrical control). Application: DAF, Mercedes Benz - Actros, Iveco
4 7 1 4 01 0 1 0 0
M22 x 1.5
4 7 1 4 01 0 0 9 2
Refered to as a "10 S4" valve. Older vehicles
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 20/53
�����
PARTS CATALOGUE 2014
RELAY EMERGENCY VALVE
281672
471 005 020 0
Port Threads
Part Number
971 002 150 0
Repair Kit
971 002 300 0
Description
2 8 16 7 2
Port 1: 1/4, Port 2: 3/8, 3/8, Port 4: 1/4, Port1-2: 3/4
2 6 67 84
Re6 Valve. Found on older trucks and trailers General Truck / Trailer / Bus
4 7 1 0 05 0 2 0 0
M22 x 1.5
4 7 1 0 05 0 0 9 2
NO Predominance.
9 7 1 0 02 1 5 0 0
M22 x 1.5
9 7 1 0 02 0 0 3 2
With Predominance (Adjustable). Alternative: 971 002 300 0 same except without Flange for manual LSV. Application: Trailer
9 7 1 0 02 3 0 0 0
Port 4: M16 x 1.5 Port 1, 1-2, 2: M22 x 1.5
9 7 1 0 02 0 0 8 2
With Dump feature. Predominance 0.3. Bar (Adjustable). For VOSS Pushin Fitting. Application: Mercedes Benz, MAN
Port Thread
Description
Application: Trailer
SHUT OFF COCK
452 002 132 0
Part Number 4 5 2 0 02 1 3 2 0 .
M22 x 1.5
Park Brake. En E ngineering Grade Plastic Handle Supercedes: 452 002 107 0
TRAILER PARK RELEASE VALVE / PARK SHUNT VALVE
963 001 051 0
971 002 900 0
Part Number
Port Thread
9 6 3 0 01 0 5 1 0 971 971 002 002 900 900 0 A6886
M16 x 1.5 M16 M16 x 1.5 1.5
Application:
Description Std park shunt valve PREV PREV Valv Valve e Park Park shun shuntt valv valve e wit with h rel relay ay emer emerge genc ncy y func functi tion on.. Appl Applic icat atio ion: n: EBS EBS trai traile lers rs PREV Valv e Information Plate 971 002 … …..
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 21/53
�����
PARTS CATALOGUE 2014
RELAY VALVE
280375
973 011 200 0 973 006 001 0 / 003 0 973 001 010 0 / 020 0 / 220 0
Part Number 2 8 03 7 5
Port Threads Port 1: 1/2, Port 2: 3/8, Port 4: 1/4
973 011 001 0/ 050 0
Repair Kit 2 6 39 45
Description R6 relay. Found on older trucks and trailers Application: General Truck / Trailer / Bus
473 017 001 0
Ports: M22 x 1.5
Anti Compound Square Square Relay Valve .
9 7 3 0 01 0 1 0 0
Ports: M22 x 1.5
9 7 3 0 01 0 0 0 2 ASA5198
Std Square Relay Application: General Truck / Trailer / Bus
9 7 3 0 01 0 2 0 0
Port 1: M22 x 1.5 Port 2, 4: M16 x 1.5
9 7 3 0 01 0 0 0 2 ASA5198
Std Square Relay Application: General Truck / Trailer / Bus
9 7 3 0 01 2 1 1 0
Port 1, 2: M22 x 1.5 Port 4: M16 x 1.5
9 7 3 0 01 0 0 6 2
Relay Valve Application: Volvo
9 7 3 0 01 2 2 0 0
Port 1: M22 x 1.5 Port 2, 4: M16 x 1.5
9 7 3 0 01 0 0 2 2
Std Square Relay Application: General Truck / Trailer / Bus
9 7 3 0 03 0 0 7 0
Ports: M22 x 1.5
9 7 3 0 03 0 0 0 2
Relay Valve Application: MAN TGA
97 3 0 0 6 00 1 0
Port 1, 2: M22 x 1.5 Port 4: M16 x 1.5
Park Brake Square Relay NO Silencer Max 10 Bar Application: Mercedes Benz, MAN
97 3 0 0 6 00 3 0
Port 1, 2: M22 x 1.5 Port 4: M16 x 1.5
Park Brake Square Relay With Silencer Silencer , Voss Threads Application: Mercedes Benz, MAN
97 3 0 1 1 00 1 0
Port 1, 2: M22 x 1.5 Port 4: M16 x 1.5
ASA7168 ASA7014
Park Brake Square Relay , Voss Threads Application: Scania, Mercedes Benz, MAN
97 3 0 1 1 02 2 0
Port 1: 1/2, Port 2: 3/8, Port 4: 1/4
ASA7168 ASA7014
With Flange For ABS Solenoid (Solenoids 472 195 082 0/30) Application: Freightliner
9 7 3 0 11 0 5 0 0
Port 1: M22 x 1.5 Port 2, 4: M16 x 1.5
9 7 3 0 11 0 0 2 2 ASA7168
Square Relay Built in Non return Application: Scania
973 011 2 00 0
Port 1, 2: M22 x 1.5 Port 41, 42: M16 x 1.5
9 7 3 0 11 0 0 0 2 ASA7168
Anti Compound Square Square Relay , Voss Voss Threads, Control 10Bar Application: Scania, MAN
9 7 3 0 11 2 0 6 0
Port 1, 2: M22 x 1.5 Port 4: M16 x 1.5
9 7 3 0 11 0 0 6 2
Voss Threads.
9 7 3 0 11 3 0 0 0
Port 1, 2: M22 x 1.5 Port 4: M16 x 1.5
9 7 3 0 11 0 0 5 2 ASA7168
Park Brake Square Relay anti compound, Voss Threads, Control 10Bar Application: Merce des Actros
9 7 3 0 11 0 0 0 0
Port 1, 2: M22 x 1.5 Port 4: M16 x 1.6
9 7 3 0 11 0 0 0 2 ASA7168
Relay valve park brake Daf
Application: Renault
Application: Volvo, Scania, Renault, Iveco,
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 22/53
�����
PARTS CATALOGUE 2014
LEVELLING VALVE
464 002 …. ….
464 006 …. ….
464 007 001 0 / 010 0
Part Number
Port Threads
4 6 4 0 02 3 3 0 0
M12 x 1.5 (3 port)
4 6 4 0 02 0 0 8 2
Two-stage. Nominal Diameter 2 x ø 1.3. With Arm. Application: Merc, MAN, Volvo, Trailer Steel Slide
4 6 4 0 02 3 3 2 0
M12 x 1.5 (3 port)
4 6 4 0 02 0 0 8 2
Two-stage. Nominal Diameter 2 x ø 1.3. Without Arm. Application: Merc Powerliner, Powerliner, MAN, MAN, Volvo Steel Slide
4 6 4 0 02 4 4 0 0
M12 x 1.5 (3 port)
4 6 4 0 02 0 0 8 2
Two-stage. Nominal Nominal Diameter Diameter 2 x ø With Arm. Application: Merc, DAF Steel Slide
4 6 4 0 06 0 0 2 0
M12 x 1.5 (3 port)
4 6 4 0 06 0 0 0 2
Two-stage. Transversal Throttle. With Linkage. Application: DAF, DAF, MAN, Volvo, Trailer Plastic Slide
4 6 4 0 06 1 0 0 0
3x M12 x 1.5 (5 port) 2x M16 x 1.5
4 6 4 0 06 0 0 1 2
Two-stage. Transversal Throttle. With Height Limitation. With Linkage. Application DAF, Trailer Plastic Slide
46 4 0 0 7 00 1 0
M6 Push in (2 port)
46 4 0 0 7 01 0 0
M10 x 1 (2 port)
464 007 013 0
M6 Push in (2 port)
Repair Kit
Description
For suspension of driver cabin. Push-in fittings for plastic tube. Application DAF, Iveco, Scania, MAN For suspension of Drivers Cabin. Application: Scania For suspension of driver cabin. Push-in fittings for plastic tube. Application DAF
RAISE / LOWER VALVE VALVE (Manual )
463 032 020 0
Part Number
Port Threads
4 6 3 0 32 0 2 0 0
Port 1: M16 x 1.5
Repair Kit 4 6 3 0 32 0 0 1 2
A6887
Description Two-stage. Nominal Diameter 2 x ø 1.3. With Arm.
Information Plate
LINE FILTER
432 500 020 0
Part Number
Port Thread
4 3 2 5 00 0 2 0 0
M22 x 1.5
Description Remov able filter
Application: Tr Trailer
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 23/53
�����
PARTS CATALOGUE 2014
CLUTCH SERVOS
970 051 111 0 / 114 0 / 126 0 / 127 0
970 051 439 0
970 051 131 0
970 051 406 0
970 051 159 0
970 051 164 0 / 176 0
970 051 414 0 / 424 0
970 150 001 0
Part Number
Port Thread
Repair Kit
Description / Application
970 051 111 0
M16 x 1.5 x 2 M14 x 1.5 x 1
Repair kit: 970 051 905 2 Dust Boot: 897 754 430 4
Diameter 80.5mm. Stroke 85mm. Application MAN
970 051 114 0
M16 x 1.5 x 2 M14 x 1.5 x 1
Repair Kit : 970 051 904 2 Dust Boot: Boot: 897 754 882 4
Diameter 75mm. Stroke 67mm. Application: DAF, Hino, Iveco, Nissan, Renault-V
970 051 126 0
M16 x 1.5 x 2 M14 x 1.5 x 1
Repair Kit : 970 051 904 2 Dust Boot: Boot: 897 754 882 4
Diameter 75mm. Stroke 67mm. Force Output 4000 N. Application: DAF, Hino, Iveco, Nissan, Renault-VI
970 051 127 0
M16 x 1.5 x 2 M14 x 1.5 x 1
Repair Kit: Kit: 970 051 906 2 Dust Boot: Boot: 897 754 182 4
Diameter 100mm. Stroke 58.5mm. Force Output 6000 N. Application: Scania
970 051 128 0
M16 x 1.5 x 2 M14 x 1.5 x 1
Repair Kit : 970 051 906 2
Diameter 108mm. Stroke 58.5mm. Application: Merc use in place of 970 051 127 0 Only Change pushrod
970 051 131 0
M16 x 1.5 x 1 M14 x 1.5 x 1
Repair Kit: Kit: 970 051 903 2 Dust Boot: Boot: 897 754 320 4 Rear Housing: 970 051 527 2
Diameter 90mm. Stroke 72mm. 72mm. Application: Merc
970 051 151 0
M16 x 1.5 x 2 M14 x 1.5 x 1
Repair Kit : 970 051 917 2
Stroke 65mm. Force Output 4000 N. Application: Merc
Dia. 90mm
970 051 157 0
M16 x 1.5 x 2 M14 x 1.5 x 1
Repair Kit : 970 051 911 2 Repair Kit : 970 051 006 2
Stroke 85mm. Force Output 6000 N.
Dia. 108mm
970 051 159 0/158 0
M16 x 1.5 x 1 M14 x 1.5 x 1
Repair Kit: Kit: 970 051 916 2
Diameter 108mm. Stroke 75mm. Application: Merc Powerliner
970 051 164 0
M16 x 1.5 x 2 M14 x 1.5 x 1
Repair Kit : 970 051 945 2 Dust Boot : 897 754 882 4
Diameter 108mm. Stroke 85mm. Application: Merc
970 051 176 0
M16 x 1.5 x 2 M14 x 1.5 x 1
970 051 950 2
Diameter 108mm. Stroke 85mm. Use 970 051 164 0 Change Pushrod On Request
970 051 405 0
M16 x 1.5
Repair Kit : 970 051 949 2
Application: Actros
970 051 406 0
M22 x 1.5 x 1 M14 x 1.5 x 1
Repair Kit: Kit: 970 051 952 2 Dust Boot: Boot: 897 754 430 4
Diameter 75mm. Stroke 85mm. Force Output Max 4000 N. Application: MAN
Repair Kit : 970 051 971 2 Sensor Kit: 970 051 986 2
970 051 412 0
Can
970 051 371 4 - guide
MAN
Superceded to 970 051 431 0
970 051 414 0
M22 x 1.5 x 1 M14 x 1.5 x 1
Repair Kit: Kit: 970 051 961 2 Dust Boot: Boot: 897 754 882 4
Diam 108mm Stroke 85mm. Force Output Max 6000 N. Mineral Oil Application: MAN / TGA/ TGL/ TGM Diameter 108mm. Stroke Stroke 85mm. Force Output Maxi 6000N Application: MAN F2000 With wear indicator
970 051 424 0 Note
M16 x 1.5 x 1 M14 x 1.5 x 1
Repair Kit: Kit: 970 051 961 2 Dust Boot: Boot: 897 754 882 4
Diameter 108mm. Stroke Stroke 85mm. Supply the 970 051 414 0 above WITH an M22-M16 reducer - Hino 700 Brake Fluid
970 051 431 0
M16 x 1.5
Repair Kit: 970 051 974 2 Dust Boot: 897 754 882 4
Diameter 108mm. Stroke 85mm. Force Output Max 6000N Merc Actros with sensor supercedes 970 051 405 0
970 051 432 0
M22 x 1.5 x 1 M14 x 1.5 x 1
Repair Kit: Kit: 970 051 977 2 Sensor:: 970 051 986 2
970 051 435 0
M16 x 1.5 x 1 M14 x 1.5 x 1
Repair Kit: Kit: 970 051 970 2
Diameter 80mm. Stroke 85mm. Force Output Max 4000N App: MAN TGA Mineral Oil Diameter 75mm. 75mm. Stroke Stroke 85mm. Force Output Maximumm 4000N With wear indicator
970 051 439 0
M16 x 1.5 x 1
Repair Kit: 970 051 984 2
Diameter 108mm Stroke 75mm. Force Output Max 6000N Application: MAN
970 051 987 2 Excl Main Seal 970 051 974 2 Incl Main Seal Repair Kit: Kit: 970 051 984 2
Diameter: 108mm Stroke Stroke 85mm. Force Output Maximumm 6200N Mineral Oil. Oil. Application: Merc Axor Diameter Stroke 75mm Application: Renault Brake Fluid
Repair Kit: Kit: 970 150 000 2
Diameter 126mm Stroke 69mm Mineral Oil MPII
970 051 441 0 970 051 438 0 970 150 001 0
M22 x 1.5 x 1 M14 x 1.5 x 1
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 24/53
App:
�����
PARTS CATALOGUE 2014
SAFETY VALVES
434 612 004 0
Part Number
Port Thread
4 3 4 6 08 2 2 0 0 434 6 12 12 00 4 0 4 3 4 6 12 0 1 4 0
M16 x 1.5 M22 x 1.5 M22 x 1.5
Description Pressure Setting 10 Bar Ap Application: Volvo Pr es ess ur ur e Setting 13 Bar Applic at ation: M er er c Benz Actr os os Pressure Setting 7.5 Bar.
NON RETURN / CHECK VALVE / SHUTTLE VALVES / ONE WAY
434 014 000 0
Part Number
Port Thread
4 3 4 0 14 0 0 0 0
M22 x 1.5
Description Female Ports Application: Trailer, Truck
DOUBLE CHECK VALVE / DIECTIONAL CONTROL / TWO WAY / CUT OFF VALVE
434 208 029 0
Part Number
Port Thread
4 3 4 2 08 0 2 9 0
M22 x 1.5
Description Female Ports W ith mounting bracket.Application: Trailer, Truck
THROTTLE CHECK VALVE (3/2 Way Valve)
463 013 111 0
Exhaust Brake Valve
463 013 210 0
Part Number
Port Thread
Repair Kit
4 6 3 0 13 1 1 1 0 4 6 3 0 13 1 1 2 0 4 6 3 0 13 1 1 4 0 4 6 3 0 13 1 1 6 0 463 0 13 13 12 1 0 4 6 3 0 13 1 3 0 0 463 463 013 013 200 200 0 463 463 013 013 210 210 0 4 6 3 0 22 0 2 0 0 8 9 1 5 00 4 6 4 4 8 1 1 4 01 1 0 0 4
M12 x 1.5 M12 x 1.5 M12 x 1.5 M12 x 1.5 M 12 x 1 . 5 M16 x 1.5 M12 M12 /M16 M16 x 1.5 1.5 M12 M12 /M16 M16 x 1.5 1.5 M 10 x 1 M 26 M 26
ASA 5705 ASA 5705 ASA 5705 ASA 5705 ASA 57 05 05 ASA 5705 ASA 5705 5705 ASA 5705 5705
463 022 020 0
Description Stroke 5.7mm. Length 39.6mm. W itithout Lock Nut. G en eneral Truck short stem Stroke 5.7mm. Length 37.9mm. W itithout Lock Nut. G en eneral Truck short stem Stroke 5.7mm. Length 37.9mm. W itithout Lock Nut. G en eneral Truck long stem Stroke 5.7mm. Length 46.9mm. W itith Lock Nut. DAF, Iveco short stem Str ok oke 5.7mm. L en ength 75.6mm On Reque st st Stroke 5.7mm. Length 37.9mm. W itithout Lock Nut. Me Merc sh short stem Stro Stroke ke 10mm 10mm.. Len Lengt gth h 41m 41mm. Wit Without hout Lock Lock Nut Nut. Mer Merc c sho short rt stem stem Stro Stroke ke 5.7m 5.7mm m. Leng Lengtth 37. 37.9mm 9mm. Wit Without hout Lock Lock Nut Nut. Merc Merc shor shortt stem stem Stroke 12.5mm. Length 42mm. W itith Lock Nut. DAF, Volvo Locknut Loose W asher Loose
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 25/53
�����
PARTS CATALOGUE 2014
GEARBOX CONTROL VALVES (3/2 Way Valve)
463 036 001 0 / 010 0
463 037 001 0
3/2 way
4/2 way
571 003 104 0
Part Number 4 6 3 0 31 1 0 2 0 463 463 036 036 001 001 0 ASA5910 4 6 3 0 36 0 2 4 0 463 463 036 036 010 010 0 4 6 3 0 36 0 1 6 0 463 463 037 037 001 001 0 4 6 3 0 38 0 0 9 0 4 6 3 0 39 0 0 6 0 463 463 063 063 002 002 0 463 463 063 063 003 003 0 4 7 2 2 60 0 0 5 0 472 2 60 60 01 1 0 5 6 3 0 20 0 0 0 0 571 0 03 03 10 4 0 571 571 040 040 000 000 0 8 9 9 8 51 8 1 0 4 8 9 1 5 00 5 2 0 4 A5821
3/2 way
571 040 000 0
5/2 way
463 039 006 0
463 031 102 0
463 063 002 0 / 003 0 5/2 way
472 260 005 0 / 011 0
Port Thread
Repair Kit 463 0 3 1 001 2
M10 M10 x 1.5 1.5 M10 x 1.5 M10 x 1.5 M16 M16 x 1.5 1.5 M16 x 1.5 Voss M10 M10 x 1.5 1.5 463 0 3 8 000 2 M 10 x 1 4 63 0 3 9 0 00 2 M10x M10x1/ 1/ M12x M12x 1.546 1.5463 3 063 063 000 000 2 M10x M10x1/ 1/ M12x M12x 1.546 1.5463 3 063 063 000 000 2 M22 x 1.5 M22 x 1.5 Vos s M 10 x 1 M 10 x 1 M14 M14 x 1.5 1.5
Description 4/2 way, Directional Control Valv e. 3/2 3/2 way, way, Wit With Turn Turnin ing g Knob Knob.. Wit With Ret Retaini aining ng Posi Posittion. ion. Wit Without hout Lock Lock Nut Nut. Merc erc 3/2 way - same as 463 036 001 0 but with W asher and Locknut 3/2 way - Pu Push button Type No W asher and Locknut 3/2 3/2 way, way, Wit Without hout Turn Turniing Knob. nob. Wit With Ret Retaini aining ng Posit ositiion. on. VOSS VOSS.. With Withou outt Lock Lock Nut Nut. Diff Lock Switch. W itith switch. Nominal Diameter 4mm. Mounting M28 x 1.5 4/3 4/3 way, way, Nomi Nomina nall Diam Diamet eter er 2.5m 2.5mm m. M10. M10. Wit Without hout Hand Handlle and and Lock Lock Nut Nut. Mer Merc c 3/2 way, Directional Contol Valve. W ith Pressure switch 3/2 way, W ithout switch. Merc 5/2 5/2 way way,, Nom Nomin inal al Diam Diamet eter er 1.5m 1.5mm. m. Merc Merc,, ZF ZF Box Box P2= P2= RHS RHS 5/2 5/2 way way,, Nomi Nomina nall Diam Diamet eter er 1.5m 1.5mm. m. MAN, MAN, ZF Box Box P2= P2= LHS LHS Proportional Valve VOITH Pro po por tition al al Valv e VOITH 3/2 way, NW 4 MAN 4/2 way , NW 4 Con tr tro l pr es es su sur e 2Bar . DAF, Me rc rc ed edes Benz, Iv ec eco, MAN 3/2 3/2 way, way, Trai Traile lerr susp suspen ensi sion on,, rais raise e lower ower & axl axle lift ift, Gene Genera rall Truc Truck k Handle for 463 037 001 0 Lock nut M28 W asher M28
Pneu Pneuma mati tic c Assis ssistt Hy Hydrau drauli lic c Serv Servo o Hydraulic Pressure: 120 Bar. Pneumatic Pressure: 8 Bar. 60cm3 Cylinder with Air Reservoir. Application: Iveco
974 974 010 010 008 008 0
3/2 way
3/2 way
SERVO UNIT 921 921 399 399 025 025 0
563 020 000 0
Pneu Pneuma mati tic c Ass Assis istt Hy Hydrau drauli lic c Mas Maste terr Ser Servo vo Supercedes 974 010 006 0 Hydraulic Pressure: 45 Bar. Pneumatic Pressure: 6 - 10 Bar.
Mineral Oil Application:
MAN TGL
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 26/53
�����
PARTS CATALOGUE 2014
SOLENOID VALVE
472 090 202 0
472 127 140 0
Part Number
Port Thread
472 09 090 20 20 2 0 472 472 070 070 639 639 0 472 0 72 72 62 8 0 4 7 2 1 02 0 4 0 0 472 472 127 127 140 140 0 4 7 2 1 32 1 9 8 0 472 17 170 60 60 0 0 472 170 637 0 472 472 172 172 600 600 0 4 7 2 1 72 6 2 0 0 4 7 2 1 72 6 2 6 0 4 7 2 1 72 6 8 6 0 4 7 2 1 74 5 0 4 0 4 7 2 1 73 7 0 0 0 472 1 76 76 31 6 0 4 7 2 1 95 0 0 0 0 4 7 2 1 23 7 0 6 0
1 /4 /4" NP NPT M16 M16 x 1.5 1.5 Vos Voss s M12 x 1.5 M12 x 1.5 M12 M12 x 1.5 1.5 M12 x 1.5 M12 x 1.5 M12 M12 x 1.5 1.5 M12 M12 x 1.5 1.5 M12 x 1.5 M12 x 1.5 M12 x 1.5 M12 x 1.5 M12 x 1.5 M16 x 1.5
472 170 600 0
472 172 686 0
472 176 3160
472 172 600 0
Description 24V No Nor ma mally cl clos ed ed. No Nominal Di Diameter 2. 2.8 mm mm. Gener al al Tr Tr uc uc k and Bu Bus 24V 24V Nor Norma mall lly y clo close sed. d. Nomi Nomina nall Dia Diam m 4mm 4mm.. DIN DIN Bayo Bayone net. t. Merc Merc 3/2 W ay ay. Nominal Diam. 2 ,2 ,2/3. Type : Nor ma mally Close d 12/24V Normally open 12/2 12/24V 4V Norm Normal ally ly clos closed ed.. Nomi Nomina nall Diam Diam 2.2m 2.2mm. m. Term Termin inal als. s. MAN, MAN, Gene Genera rall Truc Truck, k, Trai Traile lerr Nominal Diam. 2,2/3. Type: Vented 24V Norm Closed 24V No Nor ma mally cl clos ed ed. No Nominal Di Diam 4m 4mm. M2 M2 7x 7x1 Ko Ko st stal. Mer c, c, ER ERF 12V 12V Nomi Nomina nall Diam Diam.. 2,2/ 2,2/3. 3. norm normal ally ly clos closed ed 24V 24V Nor Norm mall ally cl closed osed.. Nom Nomin inal al Diam Diam 2.2m 2.2mm m. M27 M27x1 x1 Kost Kostal al.. DAF, DAF, Iveco veco,, Tra Trail iler er Nominal Diam. 2,2/3. Type: Normally closed 24V Nominal Diam. 2,2/3. Type: Normally closed 24V Normally closed DAF 24V Normally closed. 2/2 Type Bayonet 24V Nominal Diam. 4.0. Type: Normally Open Nominal Diam. 4.0. Type: Nor ma ma lllly Ope n Actr os os and DAF Use 472 195 018 0 + cable 894 601 132 2 (adaptor M24 to Bayonet) Use 472 172 620 0 24 24 V
PROPORTIONAL VALVES
Part Number
Port Thread
4 7 2 2 60 0 0 5 0 4 7 2 2 60 0 1 1 0 472 472 250 250 000 000 0
M22 Voss M22 Voss M12 M12 x 1.5 1.5
Description Truck and Bus Truck and Bus 24V 24V 8bar 8bar max. max. Speed peed limi limitter and and ASR ASR cont contro roll ller er Clos Closed ed M27x 27x 1 conn connec ecttor
OPERATING CYLINDERS
421 411 070 0
421 429 003 0
Part Number
Port Thread
421 421 411 411 070 070 0 421 421 429 429 003 003 0 4 2 1 4 11 3 0 0 0 4 2 1 4 11 3 1 4 0 4 2 1 4 29 0 0 2 0 4 2 1 4 44 0 0 2 0 4 2 1 4 45 0 0 1 0 ASA6620
M12 M12 x 1.5 1.5 M12 M12 x 1.5 1.5 M12 x 1.5 M12 x 1.5 M10 x 1.0 M12 x 1.5 1/4" NPT
421 429 002 0
422 010 012 0
Description 35m 35mm Diam Diam.. Stro Stroke ke 38mm 38mm.. With With Yoke oke 8mm 8mm. Merce Mercede des s Benz enz, ERF, RF, Iveco veco,, MAN MAN 28m 28mm Diam Diam.. Stro Stroke ke 48mm 48mm.. With Withou outt Yoke. oke. Merc Merced edes es Benz Benz,, MAN, MAN, Toyo Toyotta, Niss Nissan an 35mm Diam. St S troke 85mm. 35mm Diam. St Stroke 35mm 28mm Diam. St S troke 70mm. 20mm Diam. St Stroke 15mm 32mm Diam. St S troke 54mm Cylinder actuator assembly
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 27/53
421 411 314 0
�����
PARTS CATALOGUE 2014
DOOR CONTROL VALVES 472 472 017 017 480 480 0
Conv Conve entio ntion nal Doo oorr Con ontr tro ol 24 Volt.Normally Open or Closed 8 Bar. M12 Ports. Application: Mercedes Benz, Iveco, MAN Repair Kit 472 017 000 2
SILENCERS
432 407 060 0
432 407 070 0
Part Number
Port Thread
4 3 2 4 07 0 6 0 0 432 432 407 070 0 4 3 2 4 07 0 1 6 0
M22 x 1.5
Description Screw On, Max Pressure 13 Bar, Foot Brake Snap Snap On. On. Max Max Press Pressure ure 11 Bar, Bar, Foot Foot Brake Brake,, Loads Loadsens ensin ing g valves valves etc etc Saw - Tooth Profile
PALM COUPLINGS
952 200 021 0
952 200 022 0
Part Number
Port Thread
9 5 2 2 00 0 2 1 0 9 5 2 2 00 0 2 2 0 9 5 2 2 00 2 2 1 0 9 5 2 2 00 2 2 2 0 8 9 7 5 50 0 2 0 4
M16 x 1.5 M16 x 1.5 M16 x 1.5 M16 x 1.5
952 200 221 0
952 200 222 0
Description Red Cap, T ra railer Emergency - No Valve Yellow Cap, T ra railer Service - No Valve Red Cap, T ru ruck Emergency - W itith Valve Yellow Cap, T ru ruck Service - W ith Valv e Replacement seal
DUOMATIC COUPLINGS
452 802 009 0
452 804 012 0
Part Number
Port Thread
452 8 02 02 00 9 0 4 5 2 8 04 0 1 2 0 8 9 7 5 50 0 2 0 4
M16 x 1.5 M16 x 1.5
Description Tr uc uc k Coupling. M ax aximum 10 Bar Repa irir kit: 4 52 52 80 2 003 2 Trailer Coupling. Maximum 10 Bar Replacement seal
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 28/53
�����
PARTS CATALOGUE 2014
F&J COUPLINGS
052 001 002 2 ( 1/2" ) 052 002 002 2 ( M22 )
APSA1519 (1/2") A6722 (M22)
0520000014 ( 1/2" ) 0520000024 (M22)
0520010062 ( 1/2" )
0 52 52 00 3 00 1 2 ( 1 /2 /2 " )
1178075 ASA531/2 ( 1/2" )
052 003 006 2
0 52 52 0 01 01 00 3 2 ( 1/ 1/2 ") ")
520030022
520030052 (1/2") A6704 (M22) A1122
052 003 015 2
052 003 014 2
AP11168 ( 1/2" ) ( M22 )
A1121
A5776
Part Number
Port Thread
0 5 20 0 1 00 22 A6722 APSA1519 0520 052001 0100 0062 62 0 5 20 0 0 30 05 ASA53 SA531/ 1/2 2 0 5 20 0 1 00 32
1/2" M22 x 1.5 1/2" 1/2" 1/2" M16 x 1.5 1/2" 1/2" 1/2"
0520010022D A6722D APSA1519D 0520 052001 0100 0062 62D D 0520003005D ASA53 SA531/ 1/2D 2D 0520010032D
Female std Female with striker plug assembled Trailer Female with striker plug assembled Trailer Fema Female le F&J F&J with with shor shortt stem stem shut shut off off valv valve e Truc Truck k Female F&J with short stem shut off valve Truck Fema Femalle F&J F&J wit with shor shortt stem stem shut shut off off valv valve e Truck ruck Short stem Shut off v al alv e only
0 5 20 0 0 00 14 0 5 20 0 0 00 24 0520 052003 0300 0052 52 A6704 0 5 20 0 0 10 05 0520 052003 0300 0062 62 0 5 20 0 3 00 12 0520030112
1/2" M22 x 1.5 1/2" 1/2" M22 x 1.5 M16 x 1.5 1/2" 1/2" 1 /2 "
M22 x 1.5
0520000014D 0520000024D 0520030052D A6704D 0520001005D 0520030062D 0520030012D 0520030112D
Male Coupling std Trailer Male Coupling std Trailer Male Male F&J F&J with with long long stem stem shut shut off off valv valve e Male F&J with long stem shut off valv e Male F&J with long stem shut off valve Male Male F&J F&J with with long long stem stem shut shut off off valv valve e Long stem Shut off v alv e only Long stem Shut off valve only
AP11168 A5776 SF240/4
1/2" M22 x 1.5 1/2"
AP11168D A5776D
Striker Plug / Operating Plug Striker Plug / Operating Plug Copper W asher
0 5 20 0 3 00 22 0 5 20 0 3 01 42 1 1 78 0 7 5 A1121 A1122 0 5 20 0 3 01 52
High Spec
Description
Truc Truck k Truck Truck Truc Truck k
No dust dust flap flap or brac bracke kett No dust flap or bracket Wit With dust dust flap flap and and brac bracke kett
No dust dust cap cap or brac brack k No dust cap or bracket With With dust dust cap cap and and brac bracke kett
Dust cov er (Female dummy) for male couplings with Chain and bracket Dust Flap Nylon for Female Couplings Dust Plug male for female couplings with chain and bracket Service Tag Emergency Tag Plastic Mounting Bracket
AIR THROTTLE VALVES
361 064 050 0
Part Number 3610500002 3610640500 4230200160 8971210304 8965144404
423 020 016 0
Port Thread M14 x 1.5 M12 x 1.5
NLA
Description Repair kit Air Th Throttle Va Valves T3 Th Throttle Ac Actuator Type 3 Diaphragm fro T3 chamber Spring (A6601)
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 29/53
�����
PARTS CATALOGUE 2014
BRAKE CHAMBERS
A
B
C
Part Number
Port Thread
Pic
AGA339 AGA109 AGA448 AGA449 4 2 3 1 07 9 0 0 0 4 2 3 1 05 1 1 1 0 4 2 3 1 06 2 9 2 0 4 2 3 1 06 9 0 0 0 4 2 3 1 09 0 0 1 0 4 2 3 2 06 7 0 0 0 4 2 3 2 06 7 0 1 0 4 2 5 3 07 0 1 2 0
1/4"
A A A A B C C B C D D F
M16 x 1.5 M16 x 1.5 M16 x 1.5 M16 x 1.5 M16 x 1.5 M16 x 1.5 M16 x 1.5 M16 x 1.5 M16 x 1.5 M22 x 1.5
D
E
F
Description T 12, Short stroke T 20, Short stroke T 24, Long stroke old number AGA351 T 30, Long stroke, with nuts, clevis and washers old nummber AGA354 T 30, Long stroke, rod protrusion 85 85mm long, without clevis, nuts an and wa washers T20, 37mm Rod Protrusion. W ith Yoke and Gaiter. Merc T24, 116mm Rod Protrusion. W ith Yoke and Gaiter. Merc T24, 186mm Rod Protrusion. No yoke. T27 37mm Push Rod T24. 37mm Piston Rod. W el elded Yoke. No Mounting Studs. T24. 37mm Piston Rod. W el elded Yoke. No Mounting Studs. 100mm diam Re Release 4.5bar M16 push rod ki kit 425 307 000 2
Stroke 75mm Stroke 75mm Stroke 75mm Stroke 64mm Stroke 57mm Stroke 57mm Stroke 80mm
SPRING BRAKES WEDGE TYPE
A
Part Number
Port Thread
4 2 5 4 51 0 5 2 0 4 2 5 4 51 0 5 3 0
3/8" 3/8"
Pic A A
Description T24/24. W edge Type Right Hand Side T24/24. W edge Type Left Hand Side
SPRING BRAKES
D
B
A
C
Part Number
Port Thread
Pic
925 3 20 20 50 2 0 9 2 5 3 23 1 2 5 0 9 2 5 3 24 0 4 0 0 9 2 5 3 26 0 0 0 0 9 2 5 4 20 9 0 2 0 9 2 5 4 21 5 4 0 0 9 2 5 4 21 7 1 5 0 925 925 421 421 751 751 0 925 4 24 24 10 0 0 9 2 5 4 26 2 0 0 0 9 2 5 4 26 2 0 1 0
M16 x 1.5 M16 x 1.5 M16 x 1.5 M16 x 1.5 M22 x 1.5 M22 x 1.5 M16 x 1.5 M22 M22 x 1.5 1.5 M22 x 1.5 M22 x 1.5 M22 x 1.5
A E B A A B B D C E E
E
F
Description T2 0/ 0/30. 30mm Piston Rod. W itith Yoke and Gaiter . Re Re p Kit 9 25 253200 02 022 ( S/ S/S 9 25 25 49 0 755 0) T36/30. 15mm Push Rod. W itithout Yoke. Repair Kit 925 320 002 2 (S/S 925 494 0410 0) T16/24. 60mm W el elded Push Rod. Repair Kit 9 25 25 320 001 2 (S/S 925 490 902 0) T14/12 Wi W ith Yoke and Gaiter T20/24. 37mm W el elded Push Rod. Voss ports. R ep epair Kit 925 320 001 2 s/s 925 490 902 0 T24/30 G-Type We Welded Push Rod St Stroke 65mm T24/24. 200mm W el elded Push Rod. R ep epair Kit 925 321 007 2 NLA ( S/ S/S 925 421 752 0) T24/ 24/24. 24. 200m 200mm m Weld Welded ed Push ush Rod. Rod. MA MAN F2000 2000 (S/ (S/S 925 925 491 491 755 755 0) T1 6/ 6/24. 187mm Rod Length . W itith Yok e. e. VOSS Por ts ts . W el elded Rod.Me rc rc ( S/ S/S 92 5 494 041 0) T14/16. 15mm Push Rod. Di Disc Brake. Re Repair Kit 925 426 000 2 LHS T14/16. 15mm Push Rod. Di Disc Brake. Re Repair Kit 925 426 000 2 RHS
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 30/53
����� SPRING BRAKES
PARTS CATALOGUE 2014 Continued .. ……..
D
B
A
C
Part Number
Port Thread
Pic
9 2 5 4 50 0 0 1 0 925 4 51 51 00 1 0 925 45 452 00 00 1 0 925 4 54 54 00 1 0 9 2 5 4 24 8 0 0 0 9 2 5 4 24 8 0 1 0 9 2 5 4 61 4 7 0 0 9 2 5 4 80 0 0 4 0 9 2 5 4 88 0 1 2 0 9 2 5 4 88 0 2 1 0 9 2 5 4 92 1 0 2 0 9 2 5 4 94 0 4 1 0 9 2 5 4 81 0 1 2 0 9 2 5 4 81 0 1 3 0 9 2 5 4 68 0 1 3 0 9 2 5 4 68 0 2 0 0 AGA262 AGA445 AGA446 AGA447 AGA430 AGA431 AGA432
M16 x 1.5 M16 x 1.6 M16 x 1.7 M16 x 1.8 M22 x 1.5 M22 x 1.5 M16 x 1.5 M22 x 1.5 M22 x 1.5 M22 x 1.5 M22 x 1.5 M22 x 1.5 M16 x 1.5 M16 x 1.5 M16 x 1.5 M16 x 1.5 3/8" M16 x 1.5 M16 x 1.5 M16 x 1.5 M16 x 1.5 M16 x 1.5 M22 x 1.5
D D D D E E E E E E D D E E E E F F F F
Description
DOUBLE DIAPHRAGM SPARES
Description
8 9 5 8 01 5 1 3 2 897 750 980 4 ID12 897 751 010 4 ID21 897 753 261 4 ID35 925 3 21 21 01 0 2 9 2 5 3 22 0 11 2 A5803 ID40 ASA6194
F
T20/24. 250mm Push Ro Rod. W itithout Yoke. VOSS Ports. Superceded by 925 49 490 925 0 T2 4/ 4/24. 250mm. W itithou t Yoke. W itith Gaiter . M16 x 1.5 Ro d. d. S up uper ce ce de ded b y 9 25 25 491 141 0 T3 0/ 0/30. 25 250mm.W itithout Yo Yo ke ke. Wi With Ga Gaiter. M1 M16x1.5 Ro Rod. DA DAF,Scania,Volv o s /s /s 92 925 49 492 10 102 0 T1 6/ 6/24. 200mm. W itithou t Yoke. W itith Gaiter . M16 x 1.5 Ro d. d. Me rc rc , MAN s /s /s 925 49 4 041 0 T16/16. 15mm Rod Length. VOSS Ports. L ef eft Hand Side. MAN T16/16. 15mm Rod Length. VOSS Ports. Right Hand Side MAN T24/30. 15mm Rod Length. Stroke 65mm T20/24. 15mm Push Rod. Disc Brake. RH RH S T14/24. 15mm Push Rod. Disc Brake. RH RHS T14/24. 15mm Push Rod. Disc Brake. RH RHS T30/30. 250mm Push Rod. Universal Tri-Stop. No Yoke. T16/24. 250mm Push Rod. Universal Tri-Stop. No Yoke. ( S/ S/S 925 494 960 0) T24/24. 65mm Stroke. VOSS Ports RH R HS T24/24. Push Rod 15mm VOSS Ports. Me M erc Actros. LHS T14/24. Push Rod 15mm VOSS Ports. Merc Actros. Superseded by 925 488 015 0 LHS T14/24. Push Rod 15mm VOSS Ports. Merc Actros. Superseded by 925 488 020 0 RHS T12/12 trailers & mine machinery Pushrod 12mm T24/30 Long stroke horizontal studs trailers Pushrod M16 1/2" Clevis old number AGA349 T24/30 Long stroke Vertical studs trailers Pushrod M16 1/2" Clevis old number AGA349A T30/30 Long stroke trailers Pushrod M16 1/2" Clevis old number AGA350 T24/24 925 491 141 0 with clev is, washers and pushrod lock nut T20/24 92 925 490 925 0 with clev is, washers and pushrod lock nut T16/24 92 925 494 041 0 with clev is, washers and pushrod lock nut
SPRING BRAKE SPARES
Part Number
E
M16 x 14mm Clevis and Pin. Dust Boot. 1 Hole (Small) L=100mm W =45mm Dust Boot. 1 Hole (Large) L=100mm W=45mm Dust Boot. 2 Hole L=85mm W=45mm Type 2 4 Rear Hou si sing ( St Ste el el) . Type 30 Rear Housing (Steel). Dust Boot Maxi Maxi Booster Kit
Part Number A 59 48 ASA 1779 ASA 1780 ASA 5267
ASA6868 ASA 6294
Description Centre Seal Kit. T24 Push Rod Not for AGA349 T30 Push Rod. 5/8" Clevis x 1/2" Pin. 5/8" Clevis x 1/2" Pin (Long) Clevis M16 x 1.5mm x 1/2" Pin.
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 31/53
�����
PARTS CATALOGUE 2014
DIAPHRAGMS
Part Number 8 9 7 1 21 0 3 0 4 2 3 4 4 3 3M 2 3 4 2 2 6M 897 1 21 21 61 0 4 A6447 897 1 20 20 51 0 4 A6448 897 1 20 20 52 0 4 A2400 897 1 20 20 53 0 4 8 9 7 1 20 5 3 6 4 8 9 7 1 21 9 2 5 4 A3000 897 1 20 20 54 0 4 897 1 20 20 54 6 4 2 3 4 3 6 2M 8 9 7 1 20 5 1 6 4
Description W ab abco Type 3. OD:78.6mm D ep epth 22mm T yp e 9 . OD: 130mm T yp e 1 2 . W ab abc o Typ e 14. OD: 147mm D ep epth 3 3m 3mm T yp e 1 6 . W ab abc o Typ e 16. OD: 156mm D ep epth 3 5m 5mm T yp e 2 0 . OD: 169.7mm Depth 28.7mm W ab abc o Typ e 20. OD: 168mm D ep epth 3 3m 3mm T yp e 2 4 . OD: 180mm Depth 29mm W ab abc o Typ e 24. OD: 179mm D ep epth 3 3m 3mm W ab abco Type 24. Deep dish W abco Type 27. T yp e 3 0 . OD: 203mm Depth 32mm W ab abc o Typ e 30. OD: 199mm D ep epth 3 5m 5mm W ab abc o Typ e 30. OD: 200mm D ep epth 4 4m 4mm T yp e 3 6 . Type 16 Deep Dish
LOADSENSING & LEVELLING VALVE COMPONENTS
433 300 381 4 (STR) A 5349 LSU
ASA 5080/5081
433 300 383 4 (L)
464 002 730 2 (Levelling Valve) 475 701 712 2 (L.S.V.)
Part Number A 5 3 4 9 L SU A 5 4 26 A 5 4 27 A 6 3 56 ASA 5080 ASA 5081 433 433 300 300 381 4 433 433 300 300 383 4 433 433 300 300 384 384 4 433 433 300 300 385 385 4 433 433 401 401 003 003 0 433 40 401 00 00 4 0 433 433 401 401 380 4 464 464 002 730 2 475 475 701 701 712 712 2 475 475 710 710 130 130 4 475 475 710 710 770 770 4 441 441 050 050 718 718 2 475 475 713 713 710 710 2 898 898 011 011 350 350 4 899 14 144 63 63 1 4 A6434 A5347
Description Coiled Spring Arm for loadsensing Bracket (Springbox Mounting / Single Axle). Bracket (Springbox Mounting / Tandem Axle). Data Plate - Air Suspension Valve / Mechanical Linkage Kit Tandem Axle. Linkage Kit Single Axle. Axle Axle Linka Linkage ge Conn Connect ectio ion n 8mm 8mm (Rubb (Rubber er Strai Straight ght). ). Loads Loadsens ensin ing g Val Valve ve Axle Axle Linka Linkage ge Conn Connect ectio ion n 8mm 8mm (Rubb (Rubber er L Shap Shape). e). Loads Loadsens ensin ing g Val Valve ve Link Link Conn Connec ecti tion on 6mm 6mm (Ru (Rubb bber er L Sha Shape pe). ). Leve Levell llin ing g Val Valve ve Link Link Conn Connec ecti tion on 6mm 6mm (Ru (Rubb bber er L Sha Shape pe)) Leve Levell llin ing g Val Valve ve Axle Axle Link Linkag age e Kit. Kit. Leve Levell llin ing g Valv Valve. e. Clam Clamp p 893 893 510 510 470 470 2 Do ub uble Ax Axle Li Linkag e Kit Buffer Ki Kit Link Link Conne Connect ctio ion n 6mm 6mm (Rubb (Rubber er Strai Straigh ght) t).. Level Levelli ling ng Valve Valve No Clam Clamp p Meta Metall Arm Arm (464 (464 002. 002... ..0) 0) Level Levelli ling ng Valve Valve.. Incl Includ udes es strai straight ght rubber rubber Stra Straiight ght Loa Load d Sen Sensi sing ng Arm Arm wit with h Rub Rubbe berr Lin Link. k. Rol Roller ler (47 (475 5 710 710....0). 0). Loa Load d Sen Sensi sing ng Valve alve.. Plas Plasti tic c Plu Plung nger er (475 (475 710. 710... ..0) 0).. Loa Load d Sen Sensi sing ng Valv Valve. e. Flat Flat Bar Bar Lev Level elli ling ng Valve alve arm arm for for 464 464 002 002 532 532 0 Arm Arm and and Cabl Cable e wit with h spr sprin ing g for for 475 475 713 713 ….. ….. Loa Loads dsen ensi sing ng Valv Valve e Dust Dust Cove Coverr / Cap Cap (47 (475 5 710 710.. ...0 .0). ). Load Load Sens Sensin ing g Val Valve ve.. Da ta ta Pl Plate - Air Su Sus pe pens io io n Va lv lv e. e. Single Rubber Buffer with steel threaded rod Bottom Linkage Elbow and mounting nuts
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 32/53
�����
PARTS CATALOGUE 2014
SUZY COILS
Air Suzy
7 & 15 pin Suzy
Part Number
7 & 15 pin Plug
7 & 15 pin Socket
A6699 & A6701
A6698 & A6700
Description
ASA 5477 5477 ASA 5478 5478 AGA347 AGA348 A6700 A6701 A6698 A6699 A6624
Red Red wit with h Spr Sprin ings gs and and 1/ 1/2" NPT NPT Fit Fitttings ings.. DIN DIN Spe Speci cifi fica cattion 7337 73378. 8. Yell ellow wit with Spr Sprin ings gs and and 1/2 1/2"" NP NPT Fi Fitti ttings. ngs. DIN DIN Spe Speci cifi fica cattion ion 733 73378 78.. Electrical Male to Male 7 pin ISO 7638 ABS/EBS suzi Electrical Male to Male 15 pin ISO 12098 suzi Lighting 15 PIN ISO SOCKET Female Easy connector type Lighting 15 PIN ISO PLUG Male Easy connector type ABS/EBS 7 PIN ISO Socket Female Easy connector type ABS/EBS 7 PIN ISO Plug Male Easy connector type ABS/EBS 7 Core ADR Cable
NYLON PIPE Part Number
Description
A 5 7 66 A 6 1 15 A 6 2 32 A 6 1 14 A 6 1 19 8 2 8 2 51 9 0 8 6 A 6 0 38 A 6 0 41 A 6 2 45 A 6 2 41 8 2 8 2 51 9 0 7 6 A 5 9 14 A6244 A 5 9 12 A 6 5 99 A 3005/N/10SB 8 2 8 2 51 9 0 6 6 A 3005/N/10R
04 Black. 04 Blue. 04 Green. 0 4 Re d . 06 Blue. 06 Black. 0 6 Re d . 06 Yellow 06 Green 08 Blue 08 Black. 0 8 Re d 08 Yellow 08 Green 09 Black. 010 Blue. 010 Black 0 10 Re d .
RUBBER HOSE A3626
DIN Specification 73378 or 74324. Part Number
Description
A 3005/N/10SY A 54 05 A 5 6 06 A 5 6 35 A 56 33 A 5 6 08 A 57 82 A 56 32 A 56 34 A 56 0 7 8 28 2 5 1 9 04 6
010 Yellow. 010 Green. 011 Black (Push on). 012 Blue. 012 Green. 016 Black (Push on ). 012 Black. 0 1 2 Re d . 012 Yellow. 013 Black (Push on). 015 Black
1/2" Bore Rubber Hose Working pressure 15.5 Bar DIN: SAE J1402.
INSTALLATION ACCESSORIES AGA 322 A 9 00 899 899 700 700 001 001 4 899 899 700 700 002 002 4 899 899 700 700 003 003 4 8 9 9 7 00 0 1 2 4 8 9 9 7 00 0 1 4 4 899 899 700 700 015 015 4
Nylon Pipe Cutter Spiral Binding 25 25m lengths 8mm 8mm Nylo Nylon n Pipe Pipe Extra xtract ctiion tool ool plas plasttic 12m 12mm Nyl Nylon Pipe ipe Rele Releas ase e tool ool plas plasttic 15m 15mm Nyl Nylon Pipe ipe Rele Releas ase e tool ool plas plasttic 8mm Nylon Pipe Release tool stainless steel 12mm Ny N ylon Pipe Release tool st s tainless steel 15mm 15mm Nylo Nylon n Pipe Pipe Rele Releas ase e tool tool stai stainl nles ess s stee steell
Plastic Release Tool Stainless Steel release tool
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 33/53
�����
PARTS CATALOGUE 2014
TRUCK EBS COMPONENTS
446 130 014 0 / 015 0
Part Number
480 001 000 0
Port Thread
480 001 011 0
480 103 011 0
480 202 005 0
480 204 001/ 2 0
Description
446 130 014 0
EBS ECU (Electronic Control Unit) 4x2, 1999, with EPS/EAS. Application: Merc Actros Diagnostic Software: 246 301 547 0
446 130 015 0
EBS ECU (Electronic Control Unit) 4x2, 6x2, 6x4, 8x4. Not 4x2 tractors. 1999, with EPS/EAS. EPS/EAS. Application: Merc Actros Diagnostic Software: 246 301 547 0
446 130 053 0
EBS ECU (Electronic Control Unit) Application: Merc Actros Diagnostic Software: 246 301 547 0
480 001 000 0
All ports: M22 M22 x 1.5 Port Brake Signal Signal Transmitter Without Silencer. With port 4 4 M16 x1.5 Application: Merc Actros
480 001 010 0
M22 x 1.5 Voss
Brake Signal Transmitter With Silencer. Application: Actros
480 001 011 0
All ports: M22 x 1.5
Brake Signal Transmitter With Silencer. 2003. Without port 4 VOSS. Merc Actros
480 001 400 0
M22 x 1.5 Voss
Brake Signal Transmitter Without Silencer. Without port 4 Nissan UD 440
480 001 500 0
M22 x 1.5 Voss
Brake Signal Transmitter With Silencer. Without port 4 DAF
Application:
480 003 000 0
All ports: M22 M22 x 1.5 Port Brake Signal Transmitter With Silencer. Without port 4 4 M16 x1.5 Axor
Application:
480 103 011 0
M22 x 1.5
EBS Axle Modulator. 4x2. 1999. Application: Merc Actros / Axor
480 103 012 0
M22 x 1.5
EBS Axle Modulator. 6x2, 6x4, 8x4. 1999 Application: Merc Actros Diagnostic Software: 246 301 547 0
480 103 015 0
EBS Axle Modulator. 4x2. 2004
480 103 016 0
EBS Axle Modulator. 6x2. 2004. Application: All vehicles except 4x2
480 103 055 0
EBS Axle Modulator 6x2 Application: Merc Actros
480 104 003 0
EBS Axle Modulator. DAF
VOSS
With Port 4VOSS
480 202 004 0
All ports: M22 M22 x 1.5 Port Proportional Relay Valve. Front Axle. All vehicles except 8x4 4: M16 x1.5
480 202 005 0
All ports: M22 M22 x 1.5 Port Proportional Relay Valve. Front Axle. For 8x4 vehicles. Replaces 8840135030 4: M16 x1.5 Application: DAF 85
480 204 001 0
M22 x 1.5
480 204 002 0 480 103 042 0
EBS Trailer Control valve. Reworked 7 pin Bayonet fitting plugged plugged from below, by: 480 204 002 0 Application: DAF, Merc Actros, Nissan Not Available EBS Trailer Control valve. Reworked 7 pin Bayonet fitting plugged from below, by: 480 204 002 0 Application: DAF, Merc Merc Actros, Nissan
All ports: M22 M22 x 1.5 Port EBS Axle Modulator. DAF 4: M12 x1.5
480 103 033 0
EBS Axle Modulator. Nissan
480 104 002 0
All ports: M22 x 1.5 Port EBS Axle Modulator. Nissan (4760-001207) 4: M16 x1.5
480 104 106 0
EBS Axle Modulator MAN 2005
446 135 003 0
EBS ECU Nissan UD (4789.01273
446 210 001 0 446 210 006 0
Use
CVC Central Vehicle Controller MAN
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 34/53
Application: Application:
Superceded Superceded
�����
PARTS CATALOGUE 2014
TRUCK ABS COMPONENTS
446 004 064 0
446 004 313 0 / 416 0
Part Number
446 004 335 0
472 195 …… …
Description
446 004 064 0 446 004 416 0 446 004 335 0 472 195 006 0 472 195 016 0 472 195 018 0
ABS/ASR - C3 4S/4M. 24v. Engine Interface, EDC/EMS. Application: DAF, Dennis, Nissan Nissan 4S/4M. 24V. D Engine Interface. Application: MAN F2000 / Bus Diagnostics Software: 246 301 628 0 E Generation ECU. Basic ABS with with ASR. Application: Application: UD Nissan, Hino 700/500 Diagnostics Software: 246 301 628 0 24V ABS Solenoid Valve. Connector Kostal M24 x 1, 1/2" ports Application: Older Trucks with ABS 24V ABS Solenoid Valve. Electric Connector Bayonet. Bayonet. M22 x 1.5 VOSS Port.
472 195 052 0 472 195 082 0
12V ABS Solenoid Valve. Electric Connector: Bayonet. 1/2"-14 NPTF dry seal 12V ABS Solenoid Valve. Electric Connector Kostal M24 x 1, 1/2"BSP ports Left Hand Side Flange Mounted Application: Freightliner Freightliner
472 195 083 0
12V ABS Solenoid Valve. Electric Connector Kostal M24 x 1, 1/2"BSP ports Flange Mounted Application: Freightliner Freightliner
446 044 200 0 446 056 127 0 449 423 060 0 449 423 080 0 449 423 120 0 449 715 120 0 449 715 080 0 894 601 133 2
ABS ECU 24V ECAS Remote Control Unit Solenoid Cable 6m Solenoid Cable 8m Solenoid Cable 12m Truck Sensor cable 12M Truck Sensor cable 8M Adapter Cable Din to Bayonet
Right Hand Side
TRUCK ECAS (Electronically Controlled Air Suspension)
472 900 060 0
Part Number 472 900 053 0 472 900 060 0 472 905 111 0 473 905 114 0 472 880 001 0 446 056 116 0 446 056 202 0 446 056 010 4 446 170 208 0 441 050 011 0 441 050 012 0 441 050 100 0 472 880 000 0 441 040 007 0 441 040 015 0 441 043 504 1 441 050 123 0 441 100 531 2
463 084 010 0
446 056 116 0
441 050 011 0 /012 0
441 040 007 0 / 015 0
472 880 001 0
Description For Rear Axle with 2 Height Sensor. 3 Solenoids. 1 Electrical Connection. Bayonet. M22 x 1.5 1.5 VOSS Push-in Fitting. Fitting. With Silencer. Application: DAF, MAN, Repair Kit : 472 900 009 2 Same as 472 900 060 0 but with Plug For Rear Axle with 2 Height Sensor. 3 Solenoids. 1 Electrical Connection. Bayonet. M22 x 1.5 1.5 VOSS Push-in Fitting. Fitting. With Silencer. Repair Kit : 472 900 009 2. NO Plug but Same as 472 900 053 0 ECAS Solenoid valve drive and lift axle M22 Kit 472 905 004 2 DAF MAN TGA AXOR AXOR ECAS Solenoid valve drive and lift axle M22 2x silencers Bayonet connector ECAS Solenoid replaces 472 replaces 472 900 053 0 ECAS Remote control Hand held Truck only ECAS Remote control Hand held Universal Mounting bracket for remote control ECAS ECU Unit ECAS Height Sensor. Sensor. Bayonet without Lever. Height Sensor. Application Mercedes Benz, DAF, MAN ECAS Height Sensor. Sensor. Bayonet without Lever. Without Temperature Compensation. Application: Merc, MAN ECAS Height Sensor. Bayonet with Lever. Without Temperature Compensation. ECAS Solenoid Valve use 472 880 030 0 AXOR RA, DAF Iveco ECAS Pressure Sensor M16 x1.5 Bayonet 400 mV/Bar (16 Counts/Bar) Appl: Mercedes, DAF, Iveco, MAN, Scania, Trailer ECAS Pressure Sensor. M16 x 1.5 Bayonet. 400 mV/Bar mV/Bar (16 Counts / Bar). With O ring Pressure Sensor ECAS Height Sensor Distance Sensor Module
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 35/53
�����
PARTS CATALOGUE 2014
EBS & TCE TRAILER COMPONENTS
480 102 014 0 / 015 0
Part Number
480 207 001 0
446 122 001 0
Description
C Version EBS 971 971 002 002 802 802 0 971 002 805 0 449 449 472 472 080 080 0
EBS EBS Rela Relay y Eme Emerge rgency ncy Valve Valve C Versi Version on EBS EBS OLD OLD syst system em.. Use Use 9710 971002 0280 8050 50 bel below ow w wit ith h kit kit EBS Relay Relay Emergen Emergency cy Valve Valve rep. 9710028 9710028020 020 C Versi Version. on. Use with with 97100292 9710029212 12 or 97100292 9710029222 22 see date date of of valve valve EBS EBS CABL CABLE E to to REV REV C Versi Version on EBS EBS OLD OLD sys syste tem m Use with with 97100 97100292 29212 12 or or 9710 9710029 02922 222 2 see see date date of val valve ve
D Version EBS 480 480 102 102 015 015 0 480 480 102 102 010 010 0 480 480 102 102 014 014 0 480 480 207 207 001 001 0
EBS EBS D ECU ECU VAL VALVE VE WITH WITH RSS RSS WIT WITH H TCE TCE repl replac aces es 4801 480102 0200 0020 20 4S3M 4S3M EBS EBS D ECU ECU VALV VALVE E NO RSS RSS NO TCE TCE Basi Basic c EBS 4S2M 4S2M EBS EBS D ECU ECU VALV VALVE E WITH WITH RSS RSS NOT NOT FOR FOR TCE TCE 4S3M 4S3M EBS EBS 3rd 3rd Modu Modula lattor Rela Relay y Val Valve ve for for tra traiilers lers
441 441 040 040 015 0 449 752 030 0 449 752 100 0 449 449 823 823 020 020 0
Pressu Pressure re Trans Transduc ducer er used used wit with h ECA ECAS S and TCE TCE repla replaces ces 4410 4410400 40007 070 0 24V 24V 10 Bar Bar max max Pressure Pressure Transduc Transducer er Cabl Cable e 3m to EBS from transdu transducer cer 44104001 4410400150 50 for drawbars drawbars D -Ver -Ver EBS EBS and old EBS Pressure Pressure Transduc Transducer er Cabl Cable e 10m 10m to to EBS EBS from transdu transducer cer 4410400 4410400150 150 for drawbars drawbars D -Ver -Ver EBS EBS and old EBS Pres Pressu sure re Tran Transd sduc ucer er Cabl Cable e to to TCE TCE x44 x44 fro from m 441 44104 0400 0015 150 0 for for ECAS ECAS
4 4 9 3 72 1 3 0 0 4 4 9 6 72 0 3 0 0 449 449 172 172 120 0 449 449 272 272 100 100 0 449 449 684 313 313 0 449 449 172 172 150 0 ASA7118 449 3 77 77 03 0 0 446 446 192 192 110 110 0
EBS 3rd Modulator Cable DIAGNOSTIC PLUG CABLE 3m ELEC ELECTR TRIC ICAL AL SUPP SUPPLY LY CABL CABLE E wit with h ISO ISO67 6738 38 7pin 7pin Fem Femal ale e soc socket ket 12m ELEC ELECTR TRIC ICAL AL SUP SUPPL PLY Y CAB CABLE LE wit with h ISO ISO67 6738 38 7pi 7pin n Male Male soc socke kett 10m 10m ELEC ELEC SUP SUPPL PLY Y (sto (stopl plig ight ht)) & diag diagno nost stic ic cabl cable e 12m 12m (repl (replace aces s norma normall diag diag cabl cable) e) NOT NOT ISO7 ISO763 638 8 ELEC ELECTR TRIC ICAL AL SUPP SUPPLY LY CABL CABLE E wit with h ISO ISO67 6738 38 7pin 7pin Fem Femal ale e soc socket ket 15m 15 EXTENDED POW ER ER CABLE W IT ITH MALE FOR DRAW BA BARS Smar tb tbo ar ard ca bl ble to D ge n EBS Smar Smartb tboa oard rd EBS EBS with with batt batter ery y (Not (Not ADR ADR Comp Compli lian ant) t)
TCE Components 446 446 122 122 001 001 0 449 449 113 113 120 120 0 446 446 122 122 400 400 0 449 449 704 704 253 253 0 4 4 9 6 72 0 4 0 0 4 4 9 3 99 0 2 0 0 449 449 655 655 050 050 0 446 446 156 156 010 010 0 449 449 392 392 075 075 0
TCE TCE com compute puterr UNI UNIT Supe Superc rced edes es 446 446 122 122 000 000 0 POWE POWER R SUPP UPPLY CAB CABLE x13 x13 on TCE 15P 15PIN PARK PARK Dist Distan ance ce Cont Contro roll ller er sens sensor or TCE TCE TCE TCE To To Par Park k Dis Distt Con Contr trol ol sens sensor or Cabl Cable e 6m 6m 2 spli splitt x31 x31 TCE Diagnostic Cable x14 TCE To EBS Cable x22 ECAS ECAS/E /ELM LM fixe fixed d keyp keypad ad cable cable to TCE TCE boar board d X41 X41 use use fix fixed ed moun mountt box box 44615 4461560 6010 100 0 Fix Fixed cont contro roll key keypa pad d Box Box Mount ounted ed on vehi vehicl cle e Cabl Cable e for for rear rear ligh lighti ting ng with with 15 pin pin ISO Sock Socket et
TCE ECAS Air Susp Control Parts 472 472 900 900 055 055 0 ECA ECAS Ai Air Sus Susp p Con Conttrol rol Val Valve ve NO axle axle lift lift 4 4 9 4 83 0 1 5 0 TCE To ECAS Cable x43 446 446 056 056 202 202 0 Rem Remote ote con conttrol rol keyp keypad ad Hand Hand held held TRAI TRAILE LER R 4 4 9 6 35 0 5 0 0 TCE to IRCU Unit Cable x41 441 0 50 50 01 2 0 He ig igh t Se ns nsor Un Unit W ititho ut ut Arm 449 8 14 14 22 8 0 He ig igh t Se ns nsor Cab le le to TCE 3m x42 Additional EBS Trailer Parts (non electronic parts) 971 971 002 002 900 0 PREV PREV Valve Valve - Trail Trailer er Park Park Rele Releas ase e Val Valve ve with with relay relay emerg emergen ency cy featu feature re 973 973 500 500 051 0 Quic Quick k Rel Relea ease se Valve Valve M22 M22 & M16 M16 del del Anti Anti compo compound und valve. valve. Port 12 to Prev Prev val valve ve 434 434 500 500 003 0 Sele Select ct Low Low valve valve for for Ste Steeri ering ng Axle Axle contr control ol inst instea ead d of of usi using ng a sol soleno enoid id ASA69 60 60 EBS da data pl plate Ca Ca lc lc ul ulation In Infor ma ma tition fo for EB EBS so softw ar are
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 36/53
�����
PARTS CATALOGUE 2014
EBS E GENERATION TRAILER COMPONENTS
480 102 063 0
441 050 100 0
446 192 110 0 or 446 192 100 0
472 905 111 0/114 0
480 480 102 102 030 030 0 480 480 102 102 060 060 0 480 480 102 102 063 0 481 481 102 080 0
2S/2 2S/2M M 4S/ 4S/3M 4S/3 4S/3M M 4S/2 4S/2M M
449 449 173 173 120 120 0 449 449 273 273 120 120 0 4 4 9 3 49 1 5 0 0 4 4 9 7 23 0 3 0 0 449 72 723 10 100 0 480 20 207 00 00 1 0 472 472 195 031 0 449 42 429 08 080 0 449 43 436 03 030 0 4 4 9 6 11 0 3 0 0 441 050 100 0 449 449 811 811 000 000 0
Powe Powerr Cabl Cable e ISO 7638 7638 Semi emi - Femal emale e 12m 12m Powe Powerr Cabl Cable e ISO 7638 7638 Draw Drawba barr - male ale 12m 12m Stoplight Power ca cable 15 15m Sensor ex extension ca cable 3m Sensor ex extension ca cable 10 10m EBS 3r 3r d Modulator Re Relay Va Valv e 24V EBS EBS 3rd Modu Modula lato torr Rel Relay ay Valve Valve Mult Multivo ivolt ltag age e Same Same as VCSI VCSIII Valve Valve 3rd mo modulator ca cable to to EB EBS E 3rd mo modulator ca cable to to EB EBS E Diagnostic ca cable E-EBS 3m Distance Sensor Unit Without Arm for height control and on Mechanical suspension Dist Distan ance ce sens sensor or Conn Connec ectting cabl cable e for for EBS E
472 472 880 880 001 001 0 472 472 905 905 111 111 0 472 472 905 905 114 114 0 449 4 43 43 04 0 0 894 6 01 01 13 5 2
ECA ECAS Ai Air Sus Susp p Con Conttrol rol Val Valve ve NO axle axle lift lift ECAS ECAS Air Air Susp Susp Cont Control rol Valve Valve with with Axle Axle Lift Lift and and Opt Optit iturn urn - 1 poi point nt contr control ol ECAS ECAS Air Air Susp Susp Cont Control rol Valve Valve with with Axle Axle Lift Lift and and Opt Optit iturn urn - 2 poi point nt contr control ol Sin gl gle Ci Cir c Axle lilift Cable 4m Du al al Cir cu cuit Axle Lift Ca bl ble
446 446 192 192 110 110 0 446 446 192 192 100 100 0 4 4 9 9 11 0 4 0 0
Smar Smartb tboa oard rd EBS EBS with with batt batter ery y (Not (Not ADR ADR Comp Compli lian ant) t) Smar Smartb tboa oard rd EBS EBS witho without ut batt batter ery y (ADR (ADR Comp Compli lian ant) t) Smartboard Cable to EBS E
472 880 001 0
Prem Premiu ium m 4 GIOs GIOs - Mec Mech h Sus Susp p & Int Int Air Air susp susp With Withou outt PEM PEM Premi Premium um 7 GI GIOs - Mec Mech h Sus Susp p & Int Air Air sus susp p Prem Premiu ium m 7 GIO GIOs s - Mech Mech Susp Susp & Int Int Air Air susp susp & PEM PEM & Fitt Fittin ings gs Prem Premiu ium m 7 GIOs GIOs - Mult MultiV iVol olta tage ge ABS/ ABS/EB EBS S with with RSS RSS Witho Without ut PEM PEM
446 122 080 0 463 090 023 0 TASC Valve
446 122 070 0 ELEX
446 122 401 0/402 0 Park Distance Sensor
TASC ELEX & Park Distance Control Components 4 6 3 0 90 0 2 3 0 449 449 623 623 253 253 0 450 4 43 43 06 0 0 446 122 070 0 449 303 020 0 449 908 060 0 446 122 401 0 446 122 402 0 449 806 060 0 894 600 024 0 446 122 080 0
TASC Valve Cabl Cable e fro from m ABS ABS to TASC TASC Valv Valve e wit with h dia diagn gnos osti tic c plu plug g 6m/ 6m/6m 6m Ca bl ble fr fro m EBS E to TASC Va lv lv e 6m ELEX ECU Cable from ELEX to EBS Valve Subsys tems plug ELEX-Cable to ISO 12098 Park Distance ultrasonic sensor 0 degrees Park Distance ultrasonic sensor 15 degrees Sensor Cable to ELEX Splitter cable for Sensors Truck Remote control for trailer ELEX system
General Components 899 2 00 00 92 2 4 Stick y Silv er er Foil Data L ab abel 8 9 3 1 29 4 6 7 4 Push in to 1/2" Hose barb
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 37/53
Remote Control
�����
PARTS CATALOGUE 2014
SENSORS & ABS ACCESSORIES
441 032 808 0
441 032 921 0
Part Number
899 760 510 4
Description
449 449 712 712 023 023 0 449 449 712 712 038 038 0 449 449 712 712 051 051 0 4 4 9 0 32 9 0 5 0 441 441 032 808 0 441 441 032 032 823 823 0 441 441 032 032 851 851 0 441 0 32 32 08 2 0 441 0 32 32 92 0 0 441 0 32 32 92 1 0 441 441 100 100 110 110 0
2,3m 2,3m Sens Sensor or Ext Cabl Cable e Std Truc Truck k or Trail railer er 3,81 3,81m m Senso ensorr Ext Ext Cabl Cable e Std Std Truck ruck or Trai Trailler 5.1m 5.1m Sens Sensor or Ext Cabl Cable e Std Truc Truck k or Trail railer er ABS Sensor BPW Di Disc Caliper Senso Sensorr and and cabl cable e 0.4m 0.4m tail tail 90° Appl Applic icat atio ion: n: DAF, DAF, Merc, Merc, Trai Traile lerr Sens Sensor or Type Type S Plus Plus.. 2m tail tail 90° 90° Appl Applic icat atio ion: n: Merc Merc Actr Actros os Sens Sensor or Type Type S Plus Plus.. 1.5m 1.5m tail tail 90° 90° Appl Applic icat atio ion: n: Merc Merc Actr Actros os Sens or or S - Type T ru ruc k 3.5m 90° Sens or or S - Type T ru ruc k St Str ai aight 2 .5 .5m Sens or or S - Type Tr uc uc k Str ai aight 3 .0 .0m EDS EDS Dist Distan ance ce Sens Sensor or - Exc Exclu lusi sive ve to FTE FTE Auto Automo moti tive ve
A6609 895 905 155 4 NLA 899 760 510 4 ASA 6241
W arning Light Green round 12/24V LED Pole Wheel ( For Henred and Go Axles Only) Not Available from WABCO Sensor Bush Mounting Block
TRAILER PNEUMATIC SUSPENSION & ECAS (Electronically Controlled Air Suspension)
4741000010
Part Number
463 084 010 0
463 084 020 0
463 084 041 0
446 056 202 0
Description
463 084 020 0
Full Full Pneum Pneumati atic c Automa Automatic tic Axle Axle Lift Lift Valve Valve.. Valve Valve facto factory ry set set at at A Air ir bag bag press pressure: ure: 1.5Bar 1.5Bar lift lift A Axle xle 4.2Bar 4.2Bar lower lower
449 449 664 664 190 190 0 449 449 664 664 253 253 0 449 44 443 04 04 0 0 894 60 601 13 13 5 2 463 0 84 84 03 0 0 463 463 084 084 041 041 0
EBS EBS D Axle Axle lift lift valve valve cab cable le for Singl Single e Axl Axle e lif liftt V Val alve ve 4630 463084 8403 0300 00 4m / 4m 4m dia diag g EBS EBS D Axle Axle lift lift valve valve cab cable le for Singl Single e Axl Axle e lif liftt V Val alve ve 4630 463084 8403 0300 00 6m / 6m 6m dia diag g EBS E Single Ci Circ Ax Axle lilift Ca Ca bl ble 4m 4m EBS E Dual Ci Cir cu cuit Ax Axle Li Lift Ca Cable Sin gl gle ci circ ui uit Axle lift Valv e Sing Single le circ circui uitt Axl Axle e lif liftt Val Valve ve NEW NEW wit with h push push in in fitt fittin ings gs 8mm 8mm
463 463 084 084 010 0 449 449 624 624 113 113 0 449 449 554 554 113 113 0
EBS EBS D Dual Dual axl axle e lif liftt val valve. ve. Split Split left left and and rig right ht of trai traile lerr M16 M16 x 1.5 1.5 / M22 M22 x 1.5 1.5 EBS EBS D Axle Axle lift lift valv valve e cab cable le for for dua duall axl axle e lif liftt 463 46308 0840 4010 100 0 EBS EBS D Dia Diag g / ELM ELM / Sin Singl gle e circ circui uitt Axl Axle e lif liftt Cab Cable le 6m/2 6m/2m/ m/2m 2m
474 474 100 100 001 001 0 449 449 344 344 253 253 0 449 449 340 340 153 153 0
ELM ELM (El (Elec ecttroni ronic c Lev Level eliing Modul odule) e) M16 x 1.5 1.5 Powe Powerr cabl cable e fro from m EBS EBS ECU ECU to to ELM ELM with with EBS EBS dia diagn gnos osti tic c plu plug g Powe Powerr cab cable le from from ABS ABS ECU ECU to ELM ELM + di diagno agnost stiics
446 446 056 056 202 202 0 446 446 156 156 010 010 0 449 449 633 633 060 060 0 446 446 056 056 010 010 4 449 449 638 638 060 060 0 441 441 050 050 718 718 2
Rem Remote ote con conttrol rol keyp keypad ad Hand Hand held held TRAI TRAILE LER R Fix Fixed cont contro roll key keypa pad d Box Box Mount ounted ed on vehi vehicl cle e Remo Remote te cont contro roll Cabl Cable e to to rem remot ote e con contr trol ol hand hand held held Moun Mountting ing brac bracke kett for for rem remote ote cont contro roll Remot Remote e cont control rol Cable Cable from from ELM ELM to to remo remote te cont control rol Box Box Mou Mount nted ed on Vehi Vehicl cle e Flat Flat arm arm for for ELM ELM and and ECA ECAS S hei height ght val valve
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 38/53
�����
PARTS CATALOGUE 2014
TRAILER ABS COMPONENTS
VCSI
VCSII
400 500 035 0 / 050 0
400 500 081 0 / 083 0
Part Number
472 195 031 0
434 500 003 0
Description
TRAILER PARTS VCS I 400 500 035 0 NLA 24V ECU ECU 4S/3M 4S/3M mixed mixed Power Power supply supply stoplight stoplight power power required required with with permanent permanent power power for for diagnostics diagnostics 400 500 050 050 0 NLA 12V ECU 4S/3M Permanent Permanent Power Power supply supply required required for ABS ABS to function function,, stoplight stoplight power optional optional 449 449 411 411 140 0 NLA 3rd modul modulat ator or cable cable 14m 472 472 195 041 0 24V Bayo Bayone net. t. Boxer Boxer Valve Valve.. Double Double-A -ABS BS-Re -Rela lay y Valve Valve.. M22 x 1.5 1.5 449 449 314 314 257 257 0 Stop Stopli ligh ghtt Powe Power/ r/Di Diag agno nost stic ic cabl cable e 12/ 12/6 6 VCSI VCSI ABS ABS 449 449 332 332 120 120 0 Cons Consta tant nt Powe Powerr Cabl Cable e 12m 12m No sock socket et or plug plug VCSI VCSI ABS ABS 449 449 332 332 140 140 0 Cons Consta tant nt Powe Powerr Cab Cable le 14m 14m No sock socket et or plug plug VCSI VCSI ABS ABS 4 4 9 6 12 0 3 0 0 Diagnostic plug only TRAILER PARTS VCS II 399 399 500 500 070 070 0 24V 24V ECU ECU 2S/ 2S/2M 2M Only Only ABS ABS VCS VCS II Mixe Mixed d Pow Power er Supp Supply ly 400 400 500 500 081 081 0 24V 24V ECU ECU 2S/2 2S/2M M or or 4S/2 4S/2M M or or 4S/3 4S/3M M ABS ABS VCS VCS IIII Mix Mixed ed Pow Power er Sup Suppl ply y 400 400 500 500 083 083 0 12V 12V ECU ECU 2S/2 2S/2M M or or 4S/2 4S/2M M or or 4S/3 4S/3M M ABS ABS VCS VCS IIII Mix Mixed ed Pow Power er Sup Suppl ply y 449 449 616 616 158 158 0 VCSI VCSIII 3rd 3rd Mod Modul ulat ator or 15m 15m Cab Cable le AND AND DI DIAGNO AGNOST STIIC CAB CABLE LE 3m 449 449 616 616 153 153 0 VCSI VCSIII 3rd 3rd Mod Modul ulat ator or 6m Cabl Cable e AND AND DIAG DIAGNO NOST STIC IC CABL CABLE E 3m 449 134 337 337 0 12m 7 Pin Pin Y-Sup Y-Supply ply Cable Cable ISO ISO 7638 7638 & ISO ISO 1185 1185 WITH WITH FEMA FEMALE LE SOCK SOCKET ET - Semi Semi Traile Trailers rs (Stop (Stoplig light ht and and const constant ant power) power) 449 234 337 337 0 12m 7Pin 7Pin Y-Sup Y-Supply ply Cable Cable ISO ISO 7638 7638 & ISO ISO 1185 1185 WITH WITH MALE MALE SOCKET SOCKET -Drawba -Drawbarr Traile Trailers rs (Stop (Stoplig light ht and and const constant ant power) power) 449 6 15 15 03 0 0 Diagn os ostic Cable 3m pr ef efer ed ed u sa sage 4 4 9 6 15 0 6 0 0 Diagnostic Cable 6m 4 4 6 0 08 3 1 0 4 ISO 7638 Socket Pins 1,5 4 4 6 0 08 3 1 1 4 ISO 7638 Socket Pins 6,0 449 449 374 323 0 5 Pin Pin Y cable cable - Sem Semii and Drawb Drawbar ar Trail Trailers ers (Sto (Stopl plig ight ht suppl supply y only only)) 12m 12m Lengthening cables 449 384 333 0 449 384 328 0 449 449 133 133 120 120 0 449 449 233 233 100 100 0 ASA7 ASA707 075 5 ASA7 ASA708 080 0
6m Y-Su Y-Suppl pply y Cable Cable ISO ISO 7638 7638 & 12m ISO ISO 1185 1185 lengt lengthen hen ISO ISO cable cable with with eithe eitherr 449133 4491331200 1200 or 44923 449233100 31000 0 below below 3m Y-Su Y-Suppl pply y Cable Cable ISO ISO 7638 7638 & 12m ISO ISO 1185 1185 lengt lengthen hen ISO ISO cable cable with with eithe eitherr 449133 4491331200 1200 or 44923 449233100 31000 0 below below 12m 7 Pin Pin ISO ISO 763 7638 8 WITH WITH FEM FEMAL ALE E SOC SOCKE KET T join join to to 4493 4493843 84333 330 0 above above - Semi Semi Trail Trailers ers 10m 7 Pin Pin ISO ISO 763 7638 8 WITH WITH MALE MALE PLUG PLUG join join to 4493 4493843 84333 330 0 above above - Drawb Drawbar ar Tra Trail ilers ers Supe Superc rced eded ed 14m 14m 7 pin pin Ext Exten ende ded d Pow Power er Cab Cable le ISO 7638 7638 & ISO1 ISO118 185 5 with with Fema Female le sock socket et - LONG LONG SEMI SEMI TRAI TRAILE LERS RS Supe Superc rced eded ed 14m 14m 7 pin pin Ext Exten ende ded d Pow Power er Cabl Cable e ISO ISO 7638 7638 & IISO SO11 1185 85 with with Male Male sock socket et - DRA DRAWB WBAR AR TRAI TRAILE LERS RS
COMMON ABS PARTS FOR VCSI AND VCSII 472 195 031 0 24V 3rd Modula Modulator tor Valve, Valve, Electri Electrical cal Connect Connector: or: Bayonne Bayonnett 472 195 033 0 12V 3rd Modula Modulator tor Valve, Valve, Electric Electrical al Connect Connector: or: Bayonne Bayonnett 434 434 500 500 003 0
Ports: Ports: M22 x 1.5 (Old No. 472 195 020 0) Ports: Ports: 3/4" 3/4" supply, supply, 3/8" 3/8" deliver delivery, y, signal signal
Sele Select ct Low Low valve valve for for Ste Steeri ering ng Axle Axle contr control ol inst instea ead d of of usi using ng a sol soleno enoid id
ABS and General Plates and Labels Sticky label "WABCO ABS" A6259 Aluminium label "WABCO ABS" ABS" same text as A6259 A6602 A63 89 89 W el eld in ing wa warn in ing pl pla te te ( Th This ol old plate n ow ow r ep eplaced by by pla te te be lo low A6621 ) A6621 Diagnostics instruction data Plate replaces A6389 A6622 24V connector Plate A6623 12V connector Plate A6274 Diagnostics pl plate, next to di diagnostic pl plug A6627 A4 "Do not W eld Sticker ABS on Vehicle" A6607 Torque to 210Nm plate for spring brakes A6356 LSV Data Plate
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 39/53
�����
PARTS CATALOGUE 2014
DIAGNOSTIC EQUIPMENT
A
B
GENERAL EQUIPMENT AGA658 44 63 63010 30 300 A 44 63 63004 30 300 B 44 63 63004 00 000 B
C
D
E
F
Laptop, Diagnostic Interface II & Carry Case Diagnos titic In Inter fa fac e 2 & PC US USB ca ca bl ble S/ S/S 44 446 30 301022 0 Tr uc uck an and Tr Trailer AB ABS Ha Han dh dheld Te Tes te ter & Hy Hydr au aulic AB ABS Tr ai ailer Hand he held ABS Tes te ter C, VCS I an d VCSII G
TRAILER DIAGNOSTIC 4463 446300 0032 3292 92 44 63 63003 48 480 44 63 63003 60 600 44 63 00 3 6 10 4460 446056 5620 2020 20
CABLES CABLES C K line ine Cabl Cable e Tra Trail iler er VCSI VCSI VCS VCSII TCE TCE EBS EBS - Blu Blue e Diag Diag plug plugs s 5V CAN Cable - Yellow Diagno st stic tra ililer plug ( IV IVTM) F In te ter Ad Ad ap apter IS ISO7638 CA CAN Ca Cab le le use wi with 44 446 30 300 36 36 1 0 E 24V CAN Cable CAN use with 446 300 360 0 G ELM ELM Keypa eypad d
TRAILER SOFTWARE 4463015100 44 63 01 5 4 20 44 63 01 5 8 90 44 63 01 6 9 20
Trailer Trailer VCSII VCSII Softwa Software re USB Stick Stick Trailer EBS D So S oftware USB Stick Trailer EBS E Software USB Stick ODR - Operating Da Data Re Recorder So Software US USB St Stick
TRUCK DIAGNOSTICS CABLES 44 63 63004 04 040 H ABS/ASR D v er er s. s. Inter -A -Adap te ter Ca Cable MA MAN A6 A63 bu bus 44 63 63004 08 080 I ABS/ASR E v er er s. s. Inte rr- Ad Ad ap apter Cab le le H in ino To yo yota 44 63 00 4 5 30 DAF EBS Cable 44 63 63004 54 540 J OBD - EBS ( EP EPB) Cable MPII Actros , Axo r, r, defend er er 44 63 00 4 5 60 ECAS Diagnostic Cable 44 63 00 4 6 00 OBD - 15 pin Cable for DAF, Scania, MAN 44 63 00 3 2 70 ABS, ECAS In Inter Ad Adaptor 35 35Pin Ol Old ve version Tr Truck 44 63 00 3 1 70 ECAS / ATC Inter adapter 25pin 44 63 00 3 4 40 EBS Euro/ Asia Vehicles OLD Nissan UD 44 63 63003 40 400 K EBS / ECAS ( EP EPB) Cable ( Ac Ac tr tr os os Axor ) o ld ld c ab able 44 63 00 3 4 50 ZBR II MAN cable (TGA MAN ECAS etc) 44 63 00 3 4 90 IVECO EBS Cable TRUCK DIAGNOSTICS SOFTWARE 44 63 01 6 2 80 D+ ABS E Gen Software Hi Hino Toyota 44 63 01 6 2 40 ABS SA SAE D Gen So Software Fr Freightliner 44 63 01 8 9 80 EBS 1C Asia Software UD trucks 44 63 01 5 4 70 EBS EPB Software for Mercedes (Actros) 44 63 01 6 8 20 Diagnostic Software for Trailer TCE 44 63 01 5 4 50 Diagnostic Software for Truck EBS (Europe) 44 63 01 5 5 60 Diagnostic So Software fo for Tr Truck EB EBS (Asia) 44 63 01 5 7 20 Diagnostic Software HPB BAE software 44 63 01 8 7 40 Diagnostic Software ENR Actros/Merc ECAS 44 63 00 6 5 70 ZBR II MAN Software TGA MAN Pipe Extractor Tools 899 899 700 700 001 001 4 899 899 700 700 002 002 4 899 899 700 700 003 003 4 899 899 700 700 012 012 4 899 899 700 700 014 014 4 899 899 700 700 015 015 4
H
I
J
K
8mm 8mm 12m 12mm 15m 15mm 8mm 8mm 12mm 12mm 15mm 15mm
Nyl Nylon Pipe ipe Extr Extrac acttion ion tool ool plas plasttic Nyl Nylon Pipe ipe Rele Releas ase e tool ool plas plasttic Nyl Nylon Pipe ipe Rele Releas ase e tool ool plas plasttic Nyl Nylon Pipe ipe Rele Releas ase e tool ool stai stainl nles ess s stee steell Nylo Nylon n Pipe Pipe Rele Releas ase e tool tool stai stainl nles ess s stee steell Nylo Nylon n Pipe Pipe Rele Releas ase e tool tool stai stainl nles ess s stee steell
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 40/53
�����
PARTS CATALOGUE 2014
TEST EQUIPMENT PNEUMATIC
453 004 007 0
Part Number 453 453 004 004 007 007 0 AGA 21 211 ASA 5896* 118 118 938 938 6 A6918
AGA 211
Description Pres Pressu sure re Gaug Gauge. e. 16 Bar. Bar. M16 M16 x 1.5. 1.5. Diam Diamet eter er (100 (100mm mm). ). Pressure Ga Gauge. 10 10 Ba Bar. Dash Mo Mount. Diameter (6 (60mm). Test Hose 6m Long with W ing Nuts. Test Test Gaug Gauge e kit: kit: 2x gaug gauges es,, 2x hose hoses s 6m 6m , fitt fittin ings gs and and coup coupli ling ngs s and and test test pts pts W ing Nut for Test Gauge Hose
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 41/53
�����
PARTS CATALOGUE 2014
FITTINGS CATALOGUE
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 42/53
�����
PARTS CATALOGUE 2014
GENERAL/ COMPRESSION FITTINGS 1
UNIONS
16
SOCKETS
2
ELBOW UNIONS
17
STEEL WASHERS
3
TEE UNIONS
18
ADAPTERS
4
BULKHEADS STRAIGHT
19
TEST CONNECTORS
5
O - RINGS
20
REDUCERS
6
THRUST RINGS
21
COPPER WASHERS
7
ALUMINIUM WASHERS
22
STRAPS
8
KORS (UNION SWIVEL ADAPTERS)
23
PIPE NUTS
9
NIPPLES
24
CUTTING RINGS
10
LINE CONNECTORS
25
STEEL PIPES
11
HOSE TAILS
26
PIPE CLAMPS
12
NYLON INSERTS
13
PLUGS
14
LOCKNUTS
15
BOLTS
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 43/53
����� 1 8 9 3 8 00 2 9 4 0 8 9 3 8 00 3 0 4 0 ASA6794 8 9 3 8 00 0 1 4 0 8 9 3 8 00 2 3 4 2 8 9 3 8 00 0 4 4 0 8 9 3 8 00 9 8 4 0 8 9 3 8 00 0 6 4 0 8 9 3 8 00 2 4 4 0 8 9 3 8 00 0 7 3 0 1 6 77 0 3 9 8 9 3 8 09 0 1 0 0 8 9 3 8 09 0 2 0 0 8 9 3 8 01 9 9 4 0 8 9 3 8 00 9 7 4 0 8 9 3 8 00 0 2 2 0 8 9 3 8 00 2 2 4 0 8 9 3 8 00 1 0 9 0 8 9 3 8 00 9 6 4 0 ASA1250 8 9 3 8 00 0 3 3 0 ASA5223 ASA555 8 9 3 8 00 2 6 4 0 ASA7077 8 9 3 8 00 2 5 4 0 ASA6223 8 9 3 8 00 0 0 8 2 8 9 3 8 00 0 3 3 0
2 8 9 38 3 0 01 40 8 9 38 3 0 10 40 ASA6503 8 9 3 8 30 2 1 4 0 8 9 38 3 0 77 00 8 9 38 3 0 20 40 8 9 38 3 0 04 20 8 9 38 3 0 09 10 8 9 38 9 0 06 30 ASA5225 ASA1261 ASA1476 ASA1342 ASA1258 8 9 38 4 0 03 40 ASA1263 ASA1262 8 9 38 4 0 10 40
PARTS CATALOGUE 2014 UNIONS M 10 - 06 M 10 - 08 M 10 - 12 M 12 - 06 M 12 - 08 M 12 - 010 M 12 - 012 M 14 - 06 M 14 - 08 M 14 - 010 M 14 - 01 2 M16-06 M16-08 M16-010 M16-012 M 22 - 06 M 22 - 08 M 22 - 010 M 22 - 012 M 22 - 0 16 M22-015 Long nut and body M22-015 Short nut and body M22 -1/2" M26-015 Long Nut and Body M26-015 Short Nut and Body M26-018 Lo Long Nut Stoss M12X1-08 M22-012 M22-015 Long nut and body
ASA6548 8 93 8 0 0 3 5 4 0 8 93 8 0 0 3 7 1 0 8 93 8 0 0 9 0 4 0 8 93 8 0 1 3 1 4 0 ASA1790 ASA5208 ASA5530 ASA5182 ASA930 ASA5315 ASA5366 ASA959A ASA1025 ASA1009 ASA931 ASA5128 ASA952 ASA5806 ASA6729 893 80 0 1 34 0 A6196 ASA6766
1/8"BSP-08LL 1/4"BSP-010 1/4"BSPT-06 1/4"NPT-08 1/4"NPT-012 3/8"NPT-010 (S) 3/8"NPT-012 1/2"NPT-010 1/2"NPT-012 1/2"NPT-012 (BR) 1/2"NPT-015 1/2"BSP-012B/H 1/4"BSP-06 3/8"NPT-015 1/2"-012 B/H Brass 1/2"NPT-012 1/2"BSP-012 1/4"NPT-06 1/8"NPT-06 1/8"NPT-1/4"PIPE 3/8"NPT-010 3/8"BSP-08 1/4"NPT-1/4"PIPE
ASA5313 ASA2013 ASA2014 ASA963 ASA1235 ASA6728 ASA1435 ASA965 ASA5312 ASA6579 ASA964 ASA1237 ASA1374
1/4"NPT-012 3/8"BSP-010 3/8"BSP-012 1/4"NPT-012 1/4"NPT-06 1/2"NPT-010 3/8"NPT-012 1/2"NPT-012 Brass 1/2"NPT-012 Steel 1/4"NPT-08 3/8"NPT-012 1/8"NPT-06 1/8"NPT-08
ELBOW S M12-06 M12-08 M16-08 M16-012 B/H M22-08 B/H M22-012 B/H M22-015 M26-015 LONG NUT B/H M22(male)-M22(Female) M22-015 SHORT NUT 06SW -06 08SW -08 010SW -010 012SW -012 06-06 B/H 08-08 B/H 010-010 B/H 012-012 B/H
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 44/53
����� 3 8 9 38 6 0 01 40 8 9 38 6 0 14 40 8 9 38 6 0 05 30 8 9 38 6 0 37 40 8 9 38 6 0 09 40 8 9 38 6 0 19 40 8 9 38 6 0 39 40 8 9 38 5 0 32 40 8 9 38 5 0 39 40 ASA969 ASA5956 A844 A636 A637 ASA5414 8 9 38 5 0 66 00 A1012
4 8 9 38 2 1 39 00 ASA5255 8 9 38 2 0 16 00 8 9 38 2 0 57 40 8 9 38 9 0 01 40 8 9 38 9 0 04 00 5 8 9 70 7 1 11 04 8 9 77 7 0 07 04 8 9 77 7 0 25 04 8 9 70 8 0 40 04 8 9 77 7 0 53 04
7 8 1 14 0 1 00 84 8 1 14 0 1 17 24 8 1 14 0 1 03 24 8 1 14 0 1 04 54 8 1 14 0 1 05 74 8 1 14 0 1 06 64 8 1 14 0 1 08 04 8 1 14 0 1 10 04 9 8 9 31 0 0 03 54 8 9 31 0 0 16 44 8 9 31 8 0 03 44
PARTS CATALOGUE 2014 TEE 06-06-06 08-08-08 010-010-010 012-012-012 015-015-015 08-06-08 012-06-012 M22-012-012 M22-M22-012 012-1/4"(F)-012 012-08-012 1/4"(F)-1/4"(F)-1/4"(F) 1/4"(M)-1/4"(F)-1/4"(F) 3/8"(M)-3/8"(F)-3/8"(F) 1/8"(M)-1/8"(F)-1/8"(F) M16-012-012 1/2" HOSE TEE Steel
ASA1336 ASA1345 ASA5443 ASA5242 ASA1504 ASA1348 ASA1260 ASA1259 ASA5258 ASA5207 893 85 0 314 0 ASA6279 8 93 5 0 0 0 4 4 4 2 219 79
06SW -06-06 06-06SW -06 08SW -08-08 08-08SW -08 010SW -010-010 010-010SW -010 012SW -012-012 012-012SW -012 012SW -06-012 012SW -TEST-012 012-M22-012 Hyd Test M12x1 M22-M22-M22 1/4"-1/4"-1/4"
8938212340 8938212240 8938212440 8931039004
M16-012 M22-012 M22-015 M16-M22
BULKHEAD STRAIGHT 06-06 08-08 010-010 012-012 M22-M22 M22-1/2"BSP O-RINGS M 12 M 14 M 16 M 22 M 26
6 89 3 03 0 07 0 4 89 3 03 0 08 0 4 89 3 03 0 17 0 4 89 3 03 0 04 0 4 89 3 03 0 09 0 4 893 03 0 014 4
ALUMINIUM WASHERS M6 M 10 M 12 M 14 M 16 M 18 M 22 M 26
8
THRUST RINGS M12 M14 M16 M22 M26 M15
KORS (SW IVEL)
ASA5252 ASA5259 ASA1267 ASA1351 ASA1350 ASA5398 ASA5490
08-06 010-06 012-06 012-08 012-010 016-06 016-012
A60 A6217
1/4"NPT - 1/4"NPT 1/2"NPT - 1/2"NPT
NIPPLES M22-M22 Hex M22-1/2"BSP M16 (M (Male)-M22 (F (Female)
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 45/53
����� 10 8 9 38 2 0 01 20 8 9 38 2 0 13 40 8 9 38 2 0 02 40 8 9 38 2 0 56 40 ASA5231 8 9 38 2 0 57 40 8938 893820 2007 0700 00 ASA5261 8 9 38 2 0 08 40 ASA5237 2 0 55 1 4 ASA6188
12
PARTS CATALOGUE 2014 LINE CONNECTORS 06-06 08-08 010-010 012-012 015-015 short nut replaces 8938200610 012-012 B/H 015015-01 015 5 shor shortt nut nut B/H B/H 016-016 Short Nut 018-018 Long Nut 018-018 Short Nut 1/4"-1/4" 1/4"-1/4"B/H
06 X 1.5 08 X 1.5 10 X 1.5 12 X 1.5 15 X 1.5 18 X 1.5
13
PLUGS
14 5 0 00 1 1 0 5 0 00 4 8 4 A6001 5 0 00 1 1 2 5 0 00 1 1 3 8 1 03 1 5 00 24 8 1 03 1 5 00 34 8 1 03 1 5 00 44 8 1 03 0 4 03 14 8 1 03 1 5 00 54 8 9 15 0 0 45 44 8 9 15 0 0 46 44 8 9 15 0 0 52 04 16 8 9 32 4 0 22 44 8 9 33 0 0 01 24 8 9 33 0 0 01 14
HOSE TAILS
A24 A6735 A646 A588 A25 A23 8931294462 8931204144 8931294452 A588 A6199
3/8"NPT - 1/2" HOSE - short Fir tree 3/8"NPT - 1/2" HOSE Steel Replaces A24 M22 -1/2" HOSE Adapter hose stem pipe 12mm- 1/2" 1/4"BSPT - 1/2" HOSE 1/2"BSPT - 1/2" HOSE M22 - 1/2" 1/2" Hose Hose Tail Tail wit with Ori Oring M16 - 1/2" Hose Tail M16 - 1/2" Hose Tail with Oring Standpipe 12mm - 1/2"Hose Tail Standpipe 12mm - 1/2"Hose Tail
2 46 088 2 46 089 2 46 090
1/4" 3/8" 1/2"
ASA5974
0 4m m
A6113 A174 A31 A30 A29 A27 A28
1/8"BSP 1/8"NPT 1/4"NPT 3/8"NPT Brass 1/2"NPT Brass 1/2"BSP 3/4"NPT
NYLON INSERTS
8 9 30 4 0 21 04 8 9 30 4 0 22 04 8 9 30 4 0 23 04 8 9 30 4 0 24 04 8 9 30 4 0 25 04 8 9 30 4 0 26 04
8 1 09 0 3 00 84 8 9 30 1 0 03 04 8 9 30 1 0 01 04 8 9 30 1 0 01 14 8 9 30 1 1 71 04 8 9 30 1 1 71 14 8 1 09 0 4 00 44 8 9 30 1 0 02 04 8 9 30 1 0 23 04 8 9 30 2 2 01 44 8 9 30 2 2 01 54
11
M 10 M 12 M 14 M 14 M 16 M 16 M 16 M 22 M 26 M 16 M 22
Fine Thread
LOCKNUTS M5 M6 NYLOC M8 NYLOC M8 M 10 M 12 M 14 M 16 M16 BOOSTERS M 18 M 22 M 26 M 28
W ith O ring W ith O ring 15
BOLTS
500 01 8 6 5 00 0 24 0 50 002 4 2 50 05 52 0 5 00 02 5 3 50 00 25 0 50 00 14 1 A5668 A5669 A5999 A6000
M5x25mm M6x18mm M6x20mm M6x45mm M8x1.25x35mm M8x20mm M10x20mm M12x1,5mm Air Dryer M12x1,75mm Reserv oir M8x60mm M8x25mm
W 103/8 ASA5595 A6056
1/2"NPT BRASS 1/4" M22 -1/2"NPT
SOCKETS M 12 M22 SHORT M22 LONG
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 46/53
����� 17 5 0 00 2 2 2 5 0 00 1 3 1 5 0 00 1 2 2 A5872 8 9 51 0 4 93 04 5 0 00 5 8 2 5 0 00 5 8 3 5 0 00 5 8 4 5 0 00 5 8 5 5 0 00 5 8 7 8 1 04 2 0 01 04 A5821
19 4 6 37 0 5 10 20 4 6 37 0 3 10 60 ASA5254 4 6 37 0 3 11 40 4 6 37 0 3 10 70 ASA5867 8 9 37 8 3 94 04 ASA6279 ASA7096 4 6 3 7 03 1 1 6 0
21 A5764 A5371 A5530 A5531 SF240/4
PARTS CATALOGUE 2014 STEEL WASHERS M6 FLAT M8 FLAT M10 FLAT M18 FLAT M26 FLAT M5 SPRING M6 SPRING M8 SPRING M10 SPRING M14 SPRING M16 SPRING M28 FLAT
18 A6112 ASA6251 ASA5405 8 9 3 1 8 0 1 84 4 893 18 0 274 4 8 9 3 1 8 0 0 34 4
TEST CONNECTOR 1/4"NPT MALE M14 FEMALE M16 FEMALE M16 MALE M18 FEMALE VOSS TEST POINT RUBBER DUST BOOT COVER HYD TEST TEE 08-TP-08 TEE M12 MALE
20 A5379 A5414 A5414 A5379 8 93 1 0 4 0 66 4 893 10 4 051 4 8 93 1 0 4 0 5 2 4 A499 A498 A673 893 18 0 880 4 A34 A35 A36 A39 A672 A6181
COPPER WASHERS M 12 M 14 M 16 M 18 1/2"
23
PIPE NUTS
8 9 30 7 0 05 44 8 9 30 7 0 10 44 8 9 30 7 0 07 44 8 9 30 7 0 83 44 8 9 30 7 0 17 44 8 9 30 7 0 06 54 8 9 30 7 0 08 44
06 08 0 10 0 12 015 SHORT 015 LONG 018 LONG
22 A900 A900/B A1134 A6153
ADAPTERS 1/2"(M)-3/8"(F) 06L TAIL ONLY 08L TAIL ONLY M22 (M)-1/2" (F) M16 (M)-1/2" (F) M16(M) - M22(F) M16-M22
REDUCERS M16 - 3/8"NPT M16 (M) - 1/4" (F) M16 (M) - 1/4" (F) M16 (M) - 3/8" (F) M16 (M) - M12 (F) M22 (M) - M12 (F) M22 (M) - M16 (F) M22 (M) - 3/8"NPT (F) M22 (M) - 1/4"NPT (F) M22 (M) - 1/2"NPT (F) M26 (M)-M22 (F) 3/4"NPT (M) - 1/2"NPT (F) 1/2"-3/8" 3/8"NPT (M) - 1/4"NPT (F) 1/2" (M) - 1/4" (F) 1/2"NPT (M) - M22 (F) 1/4"NPT (M) - 1/8" (F)
W ith O ring W ith O ring W ith O ring
STRAPS Clear Spiral Binding Black Spiral Binding Plastic Straps 200mm (100Qty) Plastic Straps Heavy Duty 395mm (50Qty)
24 89 3 05 0 01 4 4 89 3 05 0 05 4 4 8 9 3 05 0 02 4 4 8 9 3 05 0 14 4 4 8 94 0 5 0 0 3 4 4 A5554 8 93 0 5 0 0 40 4 A488
CUTTING RINGS 06 08 0 10 0 12 0 15 0 16 0 18 012 Brass
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 47/53
����� 25 8 2 01 2 0 50 16 8 2 01 2 0 50 46 8 2 01 1 0 50 46 8 2 01 1 0 50 36 A3005/BU/6MM 8 2 01 2 0 57 26 8 2 01 2 0 58 16 8 2 01 2 0 57 36 A3005/S/16MM A5851 A30 05 05/BU/12MM
PARTS CATALOGUE 2014 STEEL PIPES 08 0 10 012 (PHOS.) 012 (GALV.) 06 BUNDY TUBE 015 (PHOS.) 015 (GALV.) 018 (GALV.) 0 16 016 STAINLESS 0 12 12 BUNDY TUBE
26 89 3 51 1 11 0 4 8 9 3 51 1 03 0 4 8 93 5 1 0 9 9 0 4 893 5 1 1 000 4 8 93 5 1 1 0 10 4 8 93 5 1 1 0 2 0 4 A5370 A3626 A6720 A6183
PIPE CLAMPS 06 08 0 10 01 2 0 15 0 18 1/2" Hose Clamp 1/2" Hose Clamp 20-22mm Bolt clamp Best 1/2" Hose Clamp
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 48/53
�����
PARTS CATALOGUE 2014
PUSH IN FITTINGS 1
STRAIGHT UNIONS
11
BULKHEAD UNIONS
2
MALE BULKHEAD BARREL TEE BLOCK
12
BULKHEAD ELBOWS
3
MALE BULKHEAD STUD BLOCK
13
TEES
4
MALE BULKHEAD ELBOW BLOCK
14
BRANCH TEES (ASSEMBLED)
5
FEMALE TEE BLOCK
15
BARREL TEES (ASSEMBLED)
6
M AL ALE BULKHEAD TEE BR AN ANCH BLOCK
16
TEST POINT TEES ( AS ASSEM BL BLED)
7
SCREW THREAD WITH SWIVEL PLUG
17
LINE CONNECTORS
8
SW IV IVEL PLUG ELBOW
18
VEE NUTS
9
SWIVEL PLUG BARREL TEE
19
O-RINGS
10
SWIVEL PLUG BRANCH TEE
20
THRUST RINGS
21
VARIOUS
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 49/53
����� 1 8 9 3 8 03 0 3 5 0 8 9 3 8 03 0 2 2 0 8 9 3 8 03 0 2 3 0 8 9 3 8 03 0 2 4 0 8 9 3 8 03 0 2 5 0 8 9 3 8 00 0 0 7 2 8 9 3 8 00 0 0 1 2 8 9 3 8 00 0 0 5 2 8 9 3 8 00 0 0 2 2 8 9 3 8 00 0 0 8 2 8 9 3 8 00 0 0 4 2 8 9 3 8 03 4 2 0 0 8 9 3 8 03 4 1 0 0 8 9 3 8 03 9 9 0 0 8 9 3 8 00 0 0 5 2 8 9 9 7 00 0 0 1 4 8 9 9 7 00 0 0 2 4 8 9 9 7 00 0 0 3 4 8 9 9 7 00 0 1 2 4 8 9 9 7 00 0 1 4 4 8 9 9 7 00 0 1 5 4 2 8 9 3 8 51 4 0 0 0 8 9 3 8 51 3 9 0 0 4 1 0 1 0 8 3M
PARTS CATALOGUE 2014 STRAIGHT UNIONS M10 - 6mm ( (M10x1 thread) M12 - 6mm (a (alternative 4100916M) M 16 - 6 m m M 22 - 6 m m M10 - 8x1 mm (M10x1 thread) M12 - 8x1 mm (8938034900, 4100888M) ** M16 - 8x1 mm (8938035400, 4100911M) ** M22 - 8x1 mm (8938034000, 4100913M) ** M16 - 12x1.5 mm (8 (8938034300, 41 4100915M) ** ** M22 - 12x1.5 mm (8 (8938034400, 41 4100914M) ** ** M22 - 15x1.5 mm (8 (8938037800, 41 4101056M) ** M22 - 10x1 mm M16 - 10x1 mm M26 - 15x1.5 mm M 16 - 1 6 x 1 ** ** This type of fitting has pipe removable using a tool below 8mm Nylon Pipe Extraction tool pl plastic 12mm Ny Nylon Pipe Release tool pl plastic 15mm Ny Nylon Pipe Release tool pl plastic 8mm Ny N ylon Pipe Release tool st s tainless steel 12mm Ny N ylon Pipe Release tool s ta tainless steel 15mm Ny N ylon Pipe Release tool s ta tainless steel
Plastic Tool
MALE BULKHEAD BARREL TEE BLOCK M22-M16F-M16F * (a (alternative 4101087M) M16-M16F-M16F * (a (alternative 4101086M) M12-M12F-M12F * WITH Lock nut, Thrust ring and O ring
3 4 1 0 1 0 0 5M 4 1 0 1 0 1 7M
MALE BULKHEAD STUD BLOCK M22 / M22 - M16F B/ B/H stud * (a (alternative 8931042962) M16 / M22 - M16F B/H stud * (alternative 8931042972) * WITH Lock nut, Thrust ring and O ring
4 8 9 3 4 01 0 0 8 4 8 9 3 4 01 2 9 2 4 8 9 3 4 01 7 7 0 4 8 9 3 8 90 4 5 0 0 4 1 0 1 1 0 5M 4 1 0 1 0 9 8M 4 1 0 1 1 0 2M
5 4 1 0 0 9 9 4M 8 9 3 5 01 1 9 1 4 8 9 3 5 01 1 9 7 4
6 8 9 0 1 59 5 8 6 4 4 1 0 1 0 9 6M 4101095M 4101091M A6605 A6606
MALE BULKHEAD ELBOW BLOCK M12 - M12F B/H Elbow stud * M16 - M16F B/H Elbow stud * M22 - M16F B/H Elbow stud * M22 - M22F B/H Elbow stud * M22-M16F B/H Elbow stud M12-M12F B/H Elbow stud M16-M16F B/H Elbow stu * WITHOUT Lock nut, Thrust ring and O ring FEMALE TEE BLOCK M12F - M12F - M12F TEE Block (alternative 8935010054) M16F-M16F-M16F TEE BLOCK (alternativ e 4100993M) M22-M22F-M22F TEE BLOCK (alternative 4101198M)
MALE BULKHEAD TEE BRANCH BLOCK M16F -M22 - M16F TEE Branch * M16F-M22-M16F TEE BRANCH (alternative 8901595864 *) M16F -M16 - M16F TEE Branch (alternative 8935010014 * ) M12F -M12 - M12F TEE Branch (alternative 893 501 006 4 * ) 3/8M - 1/4F - 3/8F TEE Branch (r (replaces A36 & A637) M16M -1/4F - 3/8F TEE Branch * WITHOUT Lock nut, Thrust ring and O ring
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 50/53
Stainless Steel
����� 7 8 9 3 9 20 3 4 2 4 8 9 3 1 29 1 9 1 2 8 9 3 1 29 1 9 2 2 8 9 3 1 29 1 9 3 2
8 8 9 3 4 01 8 2 7 2 8 9 3 4 01 0 1 5 2
9 8 9 3 5 01 1 9 3 4 8 9 3 5 01 1 9 4 4
10 8 9 3 5 01 1 9 5 4 8 9 3 5 01 1 9 6 4
11 ASA7098 ASA7169 ASA7099 ASA7123 ASA7124
PARTS CATALOGUE 2014 SCREW THREAD WITH SWIVEL PLUG M 10x1 Sw Swiv el Plug P5 (893 920 827 2) M 12x1.5 Swivel Plug P5 M 16x1.5 Swivel Plug P5 P5 M 22x1.5 Swivel Plug P5 P5
SWIVEL PLUG ELBOW M12x1.5 El Elbow for P5 plug M 16x1.5 Elbow for P5 plug
SWIVEL PLUG BARREL TEE M12x1.5 Ba Barrel Tee for P5 plug M 16x1.5 Barrel Tee for P5 plug
SWIVEL PLUG BRANCH TEE M12x1.5 Br Branch Tee for P5 plug M 16x1.5 Branch Tee for P5 plug
BULKHEAD UNIONS M16 - 12mm * M22 - 12mm * ( (Alternative: ASA7169) M22 - 08mm * M22 - 12mm * M1 M18 body M22 - 08mm * M1 M18 body * WITH Lock nut, Thrust ring and O ring
12 ASA7101 ASA7102 ASA7103 ASA7187
BULKHEAD ELBOW S M22 - 12mm Swiv el Type Short P5 plug (alternativ e: ASA7170) M12 - 08mm * (Alternati (Alternative: 893 831 291 0) M16 - 08mm Swiv el Type Short P5 plug (Alternativ e: 893 831 293 0 *) M 2 2 - 1 5m m * * WITH Lock nut, Thrust ring and O ring `
13 ASA7105 ASA7182 ASA7106 ASA7177 ASA7203
TEES 08 - 08 - 08 12-12-12 (Alternative: ASA7104) 15-15-15 (A (Alternative: ASA7183) 012-08-012 012-08-08
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 51/53
����� 14 ASA7107 ASA7109 ASA7164
PARTS CATALOGUE 2014 BRANCH TEES (ASSEMBLED) 012-M22-08 * (replaces: 8938510200) 012-M22-012 * (replaces 89 8938509700 and ASA7202) 08-M22-08 * * WITH Lock nut, Thrust ring and O ring
15 ASA7108 ASA7110 ASA7115
BARREL TEES (ASSEMBLED) M22-012-08 * (replaces 8938510500) M22-012-012 * M12-08-08 * (replaces 8938510600)
* WITH Lock nut, Thrust ring and O ring
16 ASA7111 ASA7112 ASA7113 ASA7114 ASA7097
TEST POINT TEES (ASSEMBLED) M 22 - T P - 0 8 * M 22 - T P - 0 1 2 * M 16 - T P - 0 1 2 * M 16 - T P - 0 8 * M 12 - T P - 0 8 * * W ITH Lock nut, Thrust ring and O ring
17 8 9 3 8 03 0 3 4 0 8 9 3 8 03 0 3 7 0 8 9 3 8 03 0 3 9 0 8 9 3 8 03 0 4 1 0
18 8 9 3 7 71 2 3 6 4 8 9 3 7 71 2 3 4 4 8 9 3 7 71 2 3 5 4 19 8 9 7 0 71 1 1 0 4 8 9 7 7 70 2 5 0 4 8 9 7 0 80 4 0 0 4 20 8 9 3 0 30 0 7 0 4 8 9 3 0 30 1 7 0 4 8 9 3 0 30 0 4 0 4
LINE CONNECTORS 6mm-6mm 08mm - 08mm (replaces 4101064M) 12mm - 12mm (replaces 4101066M) 15mm - 15mm
VEE NUTS VEE Nut 6x1 Pipe M12 VEE Nut 8x1 Pipe M14 VEE Nut 12x1.5 Pipe M18 O-RINGS M 12 M 16 M 22 THRUST RINGS M 12 M 16 M 22
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 52/53
����� 21
PARTS CATALOGUE 2014 VARIOUS
8 9 1 5 03 0 7 6 2 8 9 1 5 00 4 5 4 4
Locknut with O ring M22 Locknut withOUT O ring M22
4 1 0 1 0 5 8M 4 1 0 1 0 5 7M
M16 M Test point M12 M Test point
8 9 3 0 22 0 1 4 4 8 9 3 0 22 0 1 5 4
M16 M Plug with Oring M22 M Plug with Oring
A6735 4087055F 4087063F ASA7127
3/8" - 1/2" Hose Tail M16 - 1/2" Hose Tail with Oring M22 - 1/2" Hose Tail with Oring M16M - 1/2"hose - 1/2" hose
8 9 3 1 04 0 5 8 4
M22 Bulkhead Stud ID M16 (alternativ e 4100992M) (No Locknut)
8 9 9 3 60 2 1 0 4 8 9 9 3 60 2 6 0 4 8 9 9 3 60 1 4 0 4
Thread Filter M 12x1.5 Thread Filter M 16x1.5 Thread Filter M 22x1.5
4 1 0 1 1 6 3M A6717
M18 - M16 Socket M16 - 1/2" Socket
(alternative 4637031140) (replaces 4637020030)
(alternative 4101061F) (alternative 4087057F)
(alternative 8931294452 ) (alternativ e 8931294462)
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCO’s express written permission 53/53